MODEL 3 SERVICE MANUAL
Build 20180918_1350
MODEL 3 SERVICE MANUAL
GENERAL INFORMATION
INTRODUCTION
HOW TO USE THIS MANUAL
REPAIRS AND REPLACEMENTS
WARRANTY SERVICE REGIONS
ABBREVIATIONS AND SYMBOLS
BEST PRACTICES
ELECTRICAL PRECAUTIONS
GENERAL PRECAUTIONS
ENVIRONMENTAL PRECAUTIONS
GENERAL FITTING INSTRUCTIONS
OIL SEALS
LOCKING DEVICES
FLEXIBLE PIPES AND HOSES
WHEELS AND TIRES
AIRBAG AND SUPPLEMENTARY RESTRAINT SYSTEM (SRS) PRECAUTIONS
AIRBAG AND SUPPLEMENTARY RESTRAINT SYSTEM (SRS) COMPONENT REPLACEMENT POLICY
AIR CONDITIONING SYSTEM PRECAUTIONS
CHARGING
GENERAL
TECHNICAL DATA
MOTORS
SUSPENSION
WHEEL ALIGNMENT
BRAKES
WHEELS
TIRE PRESSURES
ELECTRICAL
IDENTIFICATION NUMBERS
VEHICLE IDENTIFICATION NUMBER (VIN)
SERIAL NUMBERS
DRIVE UNIT NUMBER
MANUFACTURING CERTIFICATION LABEL
VEHICLE PAINT CODES
FLUIDS AND CAPACITIES
00 - INSPECTION AND SERVICE
0001 - MAINTENANCE SERVICE
MAINTENANCE SERVICE AND INTERVALS
10 - BODY
1000 - VEHICLE LIFTING
RAISE VEHICLE - 2 POST LIFT
RAISE VEHICLE - 4 POST LIFT
1001 - BUMPER / FASCIA
ANKLE CATCHER (REMOVE AND REPLACE)
BRACKET - FASCIA SIDE TO FENDER - LH (REMOVE AND REPLACE)
BRACKET - REAR - CENTER (REMOVE AND REPLACE)
BRACKET - REAR WING - LH (REMOVE AND REPLACE)
BRACKET - TAILLIGHT - LH (REMOVE AND REPLACE)
BUMPER - FRONT (REMOVE AND REPLACE)
BUMPER - REAR (REMOVE AND REPLACE)
COVER - TOW HOOK (REMOVE AND REPLACE)
CRUSH CAN - FRONT - LH (REMOVE AND REPLACE)
FASCIA - FRONT (REMOVE AND INSTALL)
FASCIA - FRONT (REMOVE AND REPLACE)
FASCIA - REAR (REMOVE AND INSTALL)
FASCIA - REAR - LOWER (REMOVE AND REPLACE)
FASCIA - REAR - UPPER (REMOVE AND REPLACE)
GRILLE - FASCIA - FRONT (REMOVE AND REPLACE)
VALANCE - FRONT FASCIA (REMOVE AND REPLACE)
1010 - BODY PANELS
BRACE - SHOCK TOWER (REMOVE AND REPLACE)
BRACKET - CRASH CAN - LH (REMOVE AND REPLACE)
CARRIER - FRONT END (REMOVE AND REPLACE)
DOOR - FRONT - LH (REMOVE AND INSTALL)
DOOR - FRONT - LH (REMOVE AND REPLACE)
DOOR - REAR - LH (REMOVE AND INSTALL)
DOOR - REAR - LH (REMOVE AND REPLACE)
FENDER ASSEMBLY - FRONT - LH (REMOVE AND REPLACE)
HOOD (REMOVE AND INSTALL)
HOOD (REMOVE AND REPLACE)
TRUNK (REMOVE AND INSTALL)
TRUNK (REMOVE AND REPLACE)
1020 - WINDSHIELD AND BODY GLASS
GLASS - BACKLIGHT (REMOVE AND REPLACE)
GLASS - BODY - REAR QUARTER - LH (REMOVE AND REPLACE)
GLASS - ROOF - FIXED (REMOVE AND REPLACE)
SENSOR - RELATIVE HUMIDITY AND TEMPERATURE (REMOVE AND REPLACE)
WINDSHIELD (REMOVE AND INSTALL)
WINDSHIELD (REMOVE AND REPLACE)
1030 - PAINT
PAINT DEFECT RECTIFICATION
11 - CLOSURES
1133 - CLOSURE ASSIST MECHANISMS AND HINGES
GAS STRUT - HOOD - LH (REMOVE AND REPLACE)
GAS STRUT - TRUNK - LH (REMOVE AND REPLACE)
HINGE - HOOD - LH (REMOVE AND REPLACE)
HINGE - TRUNK - LH (REMOVE AND REPLACE)
1135 - LATCHES STRIKERS AND PINCH SENSORS
ACTUATOR - LATCH - HOOD - PRIMARY (REMOVE AND REPLACE)
ACTUATOR - LATCH - HOOD - SECONDARY (REMOVE AND REPLACE)
LATCH - DOOR - FRONT - LH (REMOVE AND REPLACE)
LATCH - DOOR - REAR - LH (REMOVE AND REPLACE)
LATCH - HOOD (REMOVE AND REPLACE)
LATCH - TRUNK (REMOVE AND REPLACE)
MANUAL RELEASE - DOOR - REAR - LH (ACTUATE)
STRIKER - DOOR - FRONT - LH (REMOVE AND REPLACE)
STRIKER - DOOR - REAR - LH (REMOVE AND REPLACE)
STRIKER - HOOD (REMOVE AND REPLACE)
STRIKER - TRUNK (REMOVE AND REPLACE)
SWITCH - EXTERIOR RELEASE - TRUNK (REMOVE AND REPLACE)
1145 - EXTERIOR DOOR HANDLES
HALL SENSOR - EXTERIOR RELEASE - DOOR - FRONT - LH (REMOVE AND REPLACE)
HALL SENSOR - EXTERIOR RELEASE - DOOR - REAR - LH (REMOVE AND REPLACE)
HANDLE - EXTERIOR RELEASE - DOOR - FRONT - LH (ADJUST)
HANDLE - EXTERIOR RELEASE - DOOR - FRONT - LH (REMOVE AND REPLACE)
HANDLE - EXTERIOR RELEASE - DOOR - REAR - LH (ADJUST)
HANDLE - EXTERIOR RELEASE - DOOR - REAR - LH (REMOVE AND REPLACE)
1150 - DOOR GLASS AND REGULATORS
GLASS - DOOR - LH - FRONT (ADJUST)
GLASS - DOOR - LH - FRONT (REMOVE AND REPLACE)
GLASS - DOOR - LH - REAR (ADJUST)
GLASS - DOOR - LH - REAR (REMOVE AND REPLACE)
SWITCH - WINDOW - DRIVER (REMOVE AND REPLACE)
SWITCH - WINDOW - FRONT PASSENGER (REMOVE AND REPLACE)
SWITCH - WINDOW - REAR (REMOVE AND REPLACE)
WINDOW MOTOR / REGULATOR ASSEMBLY - FRONT - LH (REMOVE AND REPLACE)
WINDOW MOTOR / REGULATOR ASSEMBLY - REAR - LH (REMOVE AND REPLACE)
WINDOW REGULATOR - FRONT - LH (RECALIBRATE)
WINDOW REGULATOR - REAR - LH (RECALIBRATE)
1170 - SEALS BODY CLOSURES
CLOSEOUT PANEL - DOOR - FRONT - LH (REMOVE AND INSTALL)
SEAL - BODY - SIDE - FRONT - PRIMARY - LH (REMOVE AND REPLACE)
SEAL - BODY - SIDE - REAR - PRIMARY - LH (REMOVE AND REPLACE)
SEAL - GLASS RUN - FRONT DOOR - LH (REMOVE AND REPLACE)
SEAL - HOOD (REMOVE AND REPLACE)
SEAL - INNER BELT - FRONT DOOR - LH (REMOVE AND REPLACE)
SEAL - INNER BELT - REAR DOOR - LH (REMOVE AND REPLACE)
SEAL - OUTER BELT - FRONT DOOR - LH (REMOVE AND REPLACE)
SEAL - OUTER BELT - REAR DOOR - LH (REMOVE AND REPLACE)
SEAL - SECONDARY - FRONT DOOR - LH (REMOVE AND REPLACE)
SEAL - SECONDARY - REAR DOOR - LH (REMOVE AND REPLACE)
SEAL - TRUNK (REMOVE AND REPLACE)
12 - EXTERIOR FITTINGS
1201 - WHEEL ARCH LINERS
WHEEL ARCH LINER - FRONT - LH (REMOVE AND REPLACE)
WHEEL ARCH LINER - REAR - LH (REMOVE AND REPLACE)
1203 - UNDERTRAY AND DIFFUSER
DIFFUSER - REAR FASCIA (REMOVE AND REPLACE)
PANEL - AERO SHIELD - FRONT (REMOVE AND REPLACE)
PANEL - AERO SHIELD - MID (REMOVE AND REPLACE)
1205 - BADGES AND FILMS
REAR LETTERING (RETROFIT)
TESLA BADGE - FRONT (REMOVE AND REPLACE)
TESLA BADGE - REAR (REMOVE AND REPLACE)
1207 - LICENSE PLATE MOUNTINGS
BRACKET - LICENSE PLATE - FRONT (EMEA) (RETROFIT USING JIG)
BRACKET - LICENSE PLATE - FRONT (EMEA) (RETROFIT USING TEMPLATE)
BRACKET - LICENSE PLATE - FRONT (REMOVE AND REPLACE)
BRACKET - LICENSE PLATE - FRONT (NA) (RETROFIT)
BRACKET - LICENSE PLATE - REAR (EMEA) (REMOVE AND REPLACE)
1209 - EXTERIOR MIRRORS
GLASS - DOOR MIRROR - LH (REMOVE AND REPLACE)
MIRROR - DOOR - LH (REMOVE AND REPLACE)
SKULL CAP - DOOR MIRROR - LH (REMOVE AND REPLACE)
1220 - EXTERIOR TRIM
APPLIQUE - B-PILLAR - LH (REMOVE AND REPLACE)
BRIGHTWORK - UPPER - LH (REMOVE AND REPLACE)
COVER - ROCKER PANEL - LOWER - LH (REMOVE AND REPLACE)
1222 - SPOILER
SPOILER - REAR (RETROFIT USING JIG)
SPOILER - REAR (RETROFIT USING TAPE)
1225 - UNDERHOOD TRIM
COVER - SHOCK TOWER - LH (REMOVE AND REPLACE)
PANEL - COWL SCREEN (REMOVE AND REPLACE)
UNDERHOOD APRON - REAR (REMOVE AND REPLACE)
13 - SEATS
1301 - FRONT SEAT TRACKS AND MOTORS
COVER - FRONT - SEAT TRACK - 1ST ROW SEAT (REMOVE AND REPLACE)
COVER - REAR - SEAT TRACK - 1ST ROW SEAT (REMOVE AND REPLACE)
MOTOR - RECLINER - BACKREST - DRIVER SEAT (REMOVE AND REPLACE)
MOTOR - SEAT HEIGHT - DRIVER SEAT (REMOVE AND REPLACE)
MOTOR - SEAT TILT - DRIVER SEAT (REMOVE AND REPLACE)
SWITCH - BACK REST AND CUSHION ADJUST - DRIVER SEAT (REMOVE AND REPLACE)
1304 - FRONT SEAT ASSEMBLIES AND HARDWARE
LUMBAR SUPPORT - BACKREST - DRIVER SEAT (REMOVE AND REPLACE)
SHELL - SEAT BACK - DRIVER (REMOVE AND REPLACE)
SEAT - DRIVER (REMOVE AND REPLACE)
TRIM - HEADREST - DRIVER (REMOVE AND REPLACE)
1305 - 2ND ROW SEAT ASSEMBLIES AND HARDWARE
ARMREST - 2ND ROW (REMOVE AND REPLACE)
BEZEL - HANDLE - SEAT BACK - 2ND ROW - LH (REMOVE AND REPLACE)
BOLSTER - SIDE - SEAT - 2ND ROW - LH (REMOVE AND REPLACE)
BRACKET - HINGE - SEAT BACK - 2ND ROW - LH (REMOVE AND REPLACE)
CAP - PENTHOUSE 12V (REMOVE AND REPLACE)
CAP - PENTHOUSE HV (REMOVE AND REPLACE)
CLOSEOUT - ARMREST - 2ND ROW (REMOVE AND REPLACE)
FRAME - SEAT BACK - 2ND ROW - LH (REMOVE AND REPLACE)
HANDLE - SEAT BACK - 2ND ROW - LH (REMOVE AND REPLACE)
HEADREST - 2ND ROW - CENTER (REMOVE AND REPLACE)
LATCH - SEAT BACK - 2ND ROW - LH (REMOVE AND REPLACE)
PIVOT SLEEVE - SEAT BACK - 2ND ROW - LH (REMOVE AND REPLACE)
RAIL - 2ND ROW - INNER - LH (REMOVE AND REPLACE)
RAIL - 2ND ROW - OUTER - LH (REMOVE AND REPLACE)
SEAT BACK - 2ND ROW - LH (REMOVE AND INSTALL)
SEAT BACK - 2ND ROW - RH (REMOVE AND INSTALL)
SEAT CUSHION - LOWER - 2ND ROW (REMOVE AND REPLACE)
STRIKER - SEAT BACK - 2ND ROW - LH (REMOVE AND REPLACE)
STRIKER - SEAT BACK - 2ND ROW - RH (REMOVE AND REPLACE)
1307 - FRONT SEAT COVERS PADS AND TRIMS
COVER - OUTER SIDE - DRIVER SEAT (REMOVE AND INSTALL)
FOAM - BACKREST - DRIVER SEAT (REMOVE AND REPLACE)
FOAM - CUSHION - DRIVER SEAT (REMOVE AND REPLACE)
1308 - 2ND ROW SEAT COVERS PADS AND TRIMS
COVER - SEAT BACK - 2ND ROW SEAT - RH (REMOVE AND REPLACE)
CUP HOLDER - 2ND ROW (REMOVE AND REPLACE)
14 - INSTRUMENT PANEL
1405 - INSTRUMENT PANEL
BEAM - CROSS CAR (REMOVE AND REPLACE)
COVER - AIRBAG - KNEE - DRIVER (REMOVE AND REPLACE)
COVER - AIRBAG - KNEE - FRONT PASSENGER (REMOVE AND REPLACE)
COVER - FOOTWELL - DRIVER (REMOVE AND REPLACE)
COVER - FOOTWELL - PASSENGER (LHD) (REMOVE AND REPLACE)
DAMPER - GLOVE BOX (REMOVE AND REPLACE)
DECOR TRIM - INSTRUMENT PANEL - MAIN (REMOVE AND REPLACE)
END CAP - INSTRUMENT PANEL - LH (REMOVE AND REPLACE)
FINISHER - VENT (REMOVE AND REPLACE)
GLOVE BOX (LHD) (REMOVE AND REPLACE)
GRILLE - SPEAKER - INSTRUMENT PANEL (REMOVE AND REPLACE)
HOUSING - CENTER DISPLAY (REMOVE AND REPLACE)
IP CARRIER (REMOVE AND INSTALL)
IP CARRIER (REMOVE AND REPLACE)
VENT - FRONT - LH (REMOVE AND REPLACE)
VENT - FRONT - RH (REMOVE AND REPLACE)
SOLENOID - GLOVE BOX (REMOVE AND REPLACE)
END CAP - AIR WAVE - LH (REMOVE AND REPLACE)
15 - INTERIOR TRIM
1505 - INTERIOR MIRROR AND SUN VISORS
CHECK BASE - SUN VISOR - DRIVER (REMOVE AND REPLACE)
SUN VISOR - DRIVER (REMOVE AND REPLACE)
MIRROR - REAR VIEW (REMOVE AND REPLACE)
QUAD CAMERA COVER - LOWER (REMOVE AND REPLACE)
QUAD CAMERA COVER - UPPER (REMOVE AND REPLACE)
1511 - TRUNK TRIM
GARNISH - TRUNK (REMOVE AND REPLACE)
TRIM - LID - TRUNK (REMOVE AND REPLACE)
1513 - DOOR TRIM
PANEL - DOOR TRIM - FRONT - LH (REMOVE AND INSTALL)
PANEL - DOOR TRIM - FRONT - LH (REMOVE AND REPLACE)
PANEL - DOOR TRIM - REAR - LH (REMOVE AND INSTALL)
PANEL - DOOR TRIM - REAR - LH (REMOVE AND REPLACE)
1518 - PILLAR AND SILL TRIM
FOOTREST - DRIVER (REMOVE AND REPLACE)
TRIM - A-PILLAR - LOWER - LH (REMOVE AND REPLACE)
TRIM - A-PILLAR - MIDDLE - LH (REMOVE AND REPLACE)
TRIM - A-PILLAR - UPPER - LH (REMOVE AND REPLACE)
TRIM - B-PILLAR - LOWER - LH (REMOVE AND REPLACE)
TRIM - B-PILLAR - UPPER - LH (REMOVE AND REPLACE)
TRIM - C-PILLAR - REAR - LH (REMOVE AND REPLACE)
TRIM - C-PILLAR - UPPER - LH (REMOVE AND REPLACE)
TRIM - SIDE RAIL - LH (REMOVE AND INSTALL)
TRIM - SIDE RAIL - LH (REMOVE AND REPLACE)
TRIM - SILL PANEL - REAR - LH (REMOVE AND REPLACE)
1519 - CENTER CONSOLE
ARMREST - CENTER CONSOLE (REMOVE AND REPLACE)
CARPET - SIDE PANEL - CENTER CONSOLE - LH (REMOVE AND REPLACE)
CENTER CONSOLE (REMOVE AND INSTALL)
CENTER CONSOLE (REMOVE AND REPLACE)
CUP HOLDER (REMOVE AND REPLACE)
DECOR TRIM - CENTER CONSOLE (REMOVE AND REPLACE)
END PANEL - CENTER CONSOLE (REMOVE AND REPLACE)
INSERT - FRONT BIN - CENTER CONSOLE (REMOVE AND REPLACE)
PANEL - AIR VENT - CENTER CONSOLE (REMOVE AND REPLACE)
PANEL - LOWER REAR - CENTER CONSOLE (REMOVE AND REPLACE)
PHONE TRAY - CENTER CONSOLE (REMOVE AND REPLACE)
1520 - HEADLINER
COAT HOOK - REAR - LH (REMOVE AND REPLACE)
HEADLINER (REMOVE AND INSTALL)
HEADLINER (REMOVE AND REPLACE)
OVERHEAD CONSOLE - FRONT (REMOVE AND REPLACE)
OVERHEAD CONSOLE - REAR (REMOVE AND REPLACE)
1524 - LUGGAGE COMPARTMENT TRIM
COVER - HOOD LATCH (REMOVE AND REPLACE)
SWITCH - CHILD SAFETY - UNDERHOOD STORAGE AREA (REMOVE AND REPLACE)
TRIM - FLOOR - TRUNK (REMOVE AND REPLACE)
TRIM - SIDE - TRUNK - LH (REMOVE AND REPLACE)
TRIM - SIDE - TRUNK - RH (REMOVE AND REPLACE)
TRIM - SILL - TRUNK (REMOVE AND REPLACE)
TRIM - PACKAGE TRAY (REMOVE AND INSTALL)
UNDERHOOD STORAGE UNIT (REMOVE AND REPLACE)
1530 - CARPETING AND MATS
CARPET - FRONT - LH (REMOVE AND REPLACE)
CARPET - FRONT - RH (REMOVE AND REPLACE)
OBSOLETE - CARPET - INTERIOR COMPLETE (REMOVE AND REPLACE)
CARPET - REAR (REMOVE AND REPLACE)
CARPET - REAR TRUNK (REMOVE AND REPLACE)
CARPET - UNDERHOOD STORAGE (REMOVE AND INSTALL)
16 - BATTERY SYSTEM
1601 - HV BATTERY ASSEMBLY
HV BATTERY (RWD) (REMOVE AND INSTALL)
HV BATTERY (RWD) (REMOVE AND REPLACE)
HV BATTERY (DUAL MOTOR) (REMOVE AND INSTALL)
HV BATTERY (DUAL MOTOR) (REMOVE AND REPLACE)
1610 - HV BATTERY ENCLOSURE
BREATHERS - HV BATTERY (REMOVE AND REPLACE)
COVER - HV PROBE - HV BATTERY (REMOVE AND REPLACE)
COVER - PENTHOUSE (REMOVE AND REPLACE)
FLOOD PORTS - 2ND GENERATION (REMOVE AND REPLACE)
FLOOD PORTS - 2ND GENERATION (RETROFIT)
GASKET - COVER - HV BATTERY (REMOVE AND REPLACE)
HV BATTERY AIR LEAK TEST
PENTHOUSE AIR LEAK TEST
PLATTER ENCLOSURE AIR LEAK TEST
SKI - CENTER RAIL - HV BATTERY (RWD) (REMOVE AND REPLACE)
SKI - CENTER RAIL - HV BATTERY (DUAL MOTOR) (REMOVE AND REPLACE)
SKID PLATE - HV BATTERY - FRONT (REMOVE AND REPLACE)
SKID PLATE - HV BATTERY - REAR (REMOVE AND REPLACE)
VENT ASSEMBLY - HV BATTERY - LH (REMOVE AND REPLACE)
VENT ASSEMBLY - HV BATTERY - RH (REMOVE AND REPLACE)
1620 - HV BATTERY COOLING SYSTEM
COOLANT - HV BATTERY (DRAIN AND REFILL)
PENTHOUSE COOLANT (DRAIN AND REFILL)
PENTHOUSE COOLANT LEAK TEST
PLATTER ENCLOSURE COOLANT (DRAIN AND REFILL)
PLATTER ENCLOSURE COOLANT LEAK TEST
TUBE - INPUT - COOLANT - POWER CONVERSION SYSTEM (REMOVE AND REPLACE)
TUBE - OUTPUT - COOLANT - POWER CONVERSION SYSTEM (REMOVE AND REPLACE)
1630 - HV BATTERY ELECTRICAL COMPONENTS
CONTACTOR - FAST CHARGE - HV BATTERY (REMOVE AND REPLACE)
CONTACTOR - NEGATIVE - HV BATTERY (REMOVE AND REPLACE)
CONTACTOR - POSITIVE - HV BATTERY (REMOVE AND REPLACE)
CONTROLLER - HIGH VOLTAGE (REMOVE AND REPLACE)
DC INPUT ASSEMBLY - HV BATTERY (REMOVE AND REPLACE)
FUSE - A/C COMPRESSOR - HV BATTERY (REMOVE AND REPLACE)
FUSE - CABIN HEATER - HV BATTERY (REMOVE AND REPLACE)
FUSE - POWER CONVERSION SYSTEM - HV BATTERY (REMOVE AND REPLACE)
GUIDE - PROBING - HV BATTERY (REMOVE AND REPLACE)
HARNESS - AC INLET - HV BATTERY (REMOVE AND REPLACE)
HARNESS - PENTHOUSE - HV BATTERY (REMOVE AND REPLACE)
HV BATTERY CONTACTOR SEIZE CHECK
HV HEADER - HV BATTERY (REMOVE AND REPLACE)
INSULATORS - HV BATTERY (INSTALL)
PASSTHROUGH - DCDC - 12V (REMOVE AND REPLACE)
POWER CONVERSION SYSTEM (REMOVE AND REPLACE)
PYROTECHNIC BATTERY DISCONNECT (REMOVE AND REPLACE)
SHUNT - HV BATTERY (REMOVE AND REPLACE)
17 - ELECTRICAL
1701 - 12V BATTERY AND FUSES
12V POWER (DISCONNECT AND CONNECT)
BATTERY - 12V (REMOVE AND REPLACE)
BEAM - 12V BATTERY (DUAL MOTOR) (REMOVE AND REPLACE)
BEAM - 12V BATTERY (RWD) (REMOVE AND REPLACE)
BRACKET - 12V BATTERY (DUAL MOTOR) (REMOVE AND REPLACE)
BRACKET - 12V BATTERY (RWD) (REMOVE AND REPLACE)
STRAP - 12V BATTERY (REMOVE AND REPLACE)
VEHICLE ELECTRICAL ISOLATION PROCEDURE
VENT HOSE - 12V BATTERY (REMOVE AND REPLACE)
1710 - HARNESSES
BUSBAR - DCDC GROUND (REMOVE AND REPLACE)
HARNESS - 12V BATTERY GROUND (REMOVE AND REPLACE)
HARNESS - 12V BATTERY POSITIVE (REMOVE AND REPLACE)
HARNESS - BODY - LH (REMOVE AND REPLACE)
HARNESS - BODY - RH (REMOVE AND REPLACE)
HARNESS - DOOR - FRONT - LH (REMOVE AND REPLACE)
HARNESS - DOOR - REAR - LH (REMOVE AND REPLACE)
HARNESS - DRIVE UNIT - FRONT (REMOVE AND REPLACE)
HARNESS - HEADLINER (REMOVE AND REPLACE)
HARNESS - INSTRUMENT PANEL (REMOVE AND REPLACE)
HARNESS - MAIN FRONT (REMOVE AND REPLACE)
HARNESS - SUBFRAME - REAR (REMOVE AND REPLACE)
HARNESS - THERMAL BEAM (REMOVE AND REPLACE)
HARNESS - TRUNK (REMOVE AND REPLACE)
HARNESS - WINDSHIELD (REMOVE AND REPLACE)
1715 - ELECTRONIC CONTROL MODULES
MODULE - BODY CONTROLLER - FRONT (DUAL MOTOR) (REMOVE AND REPLACE)
MODULE - BODY CONTROLLER - FRONT (RWD) (REMOVE AND REPLACE)
MODULE - BODY CONTROLLER - LH (REMOVE AND REPLACE)
MODULE - BODY CONTROLLER - RH (REMOVE AND REPLACE)
MODULE - HOMELINK TRANSMITTER (REMOVE AND REPLACE)
1720 - RADAR SENSORS
SENSOR - RADAR - FRONT (CALIBRATION)
SENSOR - RADAR - FRONT (REMOVE AND REPLACE)
1723 - FRONT CAMERAS
CAMERA - FORWARD FACING (REMOVE AND REPLACE)
CAMERA - FORWARD FACING (TARGET CALIBRATION)
1724 - INTERIOR CAMERA
CAMERA - OCCUPANT (REMOVE AND REPLACE)
1725 - REAR CAMERAS
CAMERA - REAR FACING (REMOVE AND REPLACE)
1727 - PARKING SENSORS
SENSOR - PARKING DISTANCE - FRONT - EACH (REMOVE AND REPLACE)
SENSOR - PARKING DISTANCE - REAR - EACH (REMOVE AND REPLACE)
1730 - INTERIOR SWITCHES
POWER SOCKET 12V - CENTER CONSOLE (REMOVE AND REPLACE)
SWITCH - STEERING WHEEL - LH (REMOVE AND REPLACE)
SWITCH - STEERING WHEEL - RH (REMOVE AND REPLACE)
1735 - INTERIOR LIGHTING
PUDDLE LIGHT - FRONT DOOR - LH (REMOVE AND REPLACE)
PUDDLE LIGHT - REAR DOOR - LH (REMOVE AND REPLACE)
1740 - EXTERIOR LIGHTS
ECU - HEADLIGHT (REMOVE AND REPLACE)
HEADLIGHTS - ADJUST - EMEA (TOOL METHOD)
HEADLIGHTS - ADJUST - EMEA (WALL METHOD)
HEADLIGHTS - ADJUST - NA (TOOL METHOD)
HEADLIGHTS - ADJUST - NA (WALL METHOD)
HEADLIGHT - LH (REMOVE AND REPLACE)
LIGHT - BRAKE - HIGH MOUNTED (REMOVE AND REPLACE)
LIGHT - FOG - FRONT (ADJUST)
LIGHT - FOG / REVERSE - REAR - LH (REMOVE AND REPLACE)
LIGHT - LICENSE PLATE (REMOVE AND REPLACE)
LIGHT - SIDE REPEATER - FRONT - LH (REMOVE AND REPLACE)
LIGHT - TURN SIGNAL / FOG - FRONT - LH (REMOVE AND REPLACE)
TAILLIGHT - LH (REMOVE AND REPLACE)
REFLEX LENS - REAR - RH (REMOVE AND REPLACE)
REFLECTOR - FASCIA - REAR - LH (REMOVE AND REPLACE)
1745 - KEYLESS ENTRY AND SECURITY
ANTENNA - BLUETOOTH PASSIVE ENTRY - FRONT (REMOVE AND REPLACE)
ANTENNA - BLUETOOTH PASSIVE ENTRY - REAR (REMOVE AND REPLACE)
KEY – PROGRAMMING (WITH AUTHENTICATED KEY PRESENT)
MODULE - BODY CONTROLLER - SECURITY (REMOVE AND REPLACE)
SIREN - BATTERY BACKED (REMOVE AND REPLACE)
1750 - WIPERS AND WASHERS
RESERVOIR - WINDSHIELD WASHER (REMOVE AND REPLACE)
WIPER MOTOR (REMOVE AND REPLACE)
WIPER ARMS (REMOVE AND REPLACE)
WIPER BLADES (ADJUST)
WIPER BLADES (REMOVE AND REPLACE)
1753 - HORNS
HORN - HIGH TONE (REMOVE AND REPLACE)
HORN - LOW TONE (REMOVE AND REPLACE)
1754 - PEDESTRIAN WARNING SPEAKER
SPEAKER - PEDESTRIAN WARNING (REMOVE AND REPLACE)
1755 - ACCELERATOR PEDAL
ACCELERATOR (REMOVE AND REPLACE)
18 - THERMAL MANAGEMENT
1810 - CABIN HVAC
ACTUATOR - BLEED - LH (REMOVE AND REPLACE)
ACTUATOR - INTAKE (REMOVE AND REPLACE)
ACTUATOR - LOWER MODE (REMOVE AND REPLACE)
ACTUATOR - UPPER MODE (REMOVE AND REPLACE)
ACTUATOR - VENT - LH (REMOVE AND REPLACE)
ACTUATOR - VENT - RH (REMOVE AND REPLACE)
AIR EXTRACTOR - LH (REMOVE AND REPLACE)
DUCT - AIR WAVE - LH (REMOVE AND REPLACE)
DUCT - AIR WAVE - RH (REMOVE AND REPLACE)
DUCT - CABIN INTAKE (REMOVE AND REPLACE)
DUCT - FOOTWELL - LH (REMOVE AND REPLACE)
DUCT - FOOTWELL - RH (REMOVE AND REPLACE)
DUCT - HVAC PLENUM - INNER (REMOVE AND REPLACE)
DUCT - HVAC PLENUM - OUTER (REMOVE AND REPLACE)
FILTER - CABIN (REMOVE AND REPLACE)
HEATER - PTC (REMOVE AND REPLACE)
HVAC ASSEMBLY (REMOVE AND REPLACE)
BLOWER MOTOR - HVAC (REMOVE AND REPLACE)
SENSOR - AMBIENT AIR TEMPERATURE (REMOVE AND REPLACE)
SENSOR - CABIN TEMPERATURE (REMOVE AND REPLACE)
SENSOR - TEMPERATURE - EVAPORATOR (REMOVE AND REPLACE)
SENSOR - TEMPERATURE - LH (REMOVE AND REPLACE)
SENSOR - TEMPERATURE - RH (REMOVE AND REPLACE)
1820 - REFRIGERANT SYSTEM
A/C REFRIGERANT LEAK DETECTION
A/C REFRIGERANT (RECOVERY AND RECHARGE)
CHILLER AND EXV ASSEMBLY (REMOVE AND REPLACE)
COMPRESSOR (REMOVE AND REPLACE)
CONDENSER (REMOVE AND REPLACE)
EVAPORATOR (CLEAN)
EVAPORATOR (REMOVE AND REPLACE)
MODULE - COOLING FAN (REMOVE AND INSTALL)
MODULE - COOLING FAN (REMOVE AND REPLACE)
MOUNTING - A/C COMPRESSOR (REMOVE AND REPLACE)
PIPE - HIGH PRESSURE - COMPRESSOR TO CONDENSER (REMOVE AND REPLACE)
PIPES - REFRIGERANT - HIGH / LOW PRESSURE (REMOVE AND REPLACE)
PRESSURE TRANSDUCER - HIGH PRESSURE (REMOVE AND REPLACE)
PRESSURE TRANSDUCER - LOW PRESSURE (REMOVE AND REPLACE)
RECEIVER DRYER AND DESICCANT (REMOVE AND REPLACE)
TXV VALVE - EVAPORATOR (REMOVE AND REPLACE)
1830 - COOLING SYSTEM
5-WAY VALVE (REMOVE AND REPLACE)
ACTUATOR - 5-WAY VALVE (DUAL MOTOR) (REMOVE AND REPLACE)
ACTUATOR - 5-WAY VALVE (RWD) (REMOVE AND REPLACE)
COOLANT PUMP - HV BATTERY (REMOVE AND REPLACE)
COOLANT PUMP - POWERTRAIN (REMOVE AND REPLACE)
COOLING SYSTEM (CHECK AND FILL)
COOLING SYSTEM (DRAIN AND REFILL)
COOLING SYSTEM (PARTIAL REFILL AND BLEED)
COOLING SYSTEM (VACUUM REFILL)
HOSE - CHILLER TO CAR COMPUTER AND HV BATTERY SUPPLY MANIFOLD (DUAL MOTOR) (REMOVE AND REPLACE)
HOSE - RETURN - HV BATTERY (REMOVE AND REPLACE)
HOSE - RETURN - POWERTRAIN (REMOVE AND REPLACE)
HOSE - SUPPLY - POWERTRAIN (REMOVE AND REPLACE)
RADIATOR (REMOVE AND REPLACE)
SUPERBOTTLE (DUAL MOTOR) (REMOVE AND REPLACE)
SUPERBOTTLE (RWD) (REMOVE AND REPLACE)
1850 - AIR DISTRIBUTION
ACTIVE GRILLE SHUTTER (REMOVE AND REPLACE)
20 - SAFETY AND RESTRAINT
2001 - AIRBAGS
AIRBAG - CURTAIN - LH (REMOVE AND REPLACE)
AIRBAG - DRIVER (REMOVE AND REPLACE)
AIRBAG - FRONT PASSENGER (REMOVE AND INSTALL)
AIRBAG - FRONT PASSENGER (REMOVE AND REPLACE)
AIRBAG - KNEE - DRIVER (REMOVE AND INSTALL)
AIRBAG - KNEE - DRIVER (REMOVE AND REPLACE)
AIRBAG - KNEE - FRONT PASSENGER (REMOVE AND REPLACE)
AIRBAG - SIDE - DRIVER (REMOVE AND REPLACE)
MODULE - RESTRAINT CONTROL (REMOVE AND REPLACE)
2005 - SEATBELTS
BUCKLE - 1ST ROW - LH (REMOVE AND REPLACE)
BUCKLE - 2ND ROW - CENTER (REMOVE AND REPLACE)
BUCKLE - 2ND ROW - LH (REMOVE AND REPLACE)
ADJUSTABLE TOP LOOP (REMOVE AND REPLACE)
SEATBELT - 1ST ROW - LH (REMOVE AND REPLACE)
SEATBELT - 2ND ROW - CENTER (REMOVE AND REPLACE)
SEATBELT - 2ND ROW - LH (REMOVE AND REPLACE)
2010 - PRETENSIONERS
PRETENSIONER - OUTBOARD LAP - 1ST ROW - LH (REMOVE AND REPLACE)
2020 - SENSORS
SENSOR - AIRBAG - B-PILLAR - LH (REMOVE AND REPLACE)
SENSOR - AIRBAG - C-PILLAR - LH (REMOVE AND REPLACE)
SENSOR - AIRBAG - DOOR - FRONT (REMOVE AND REPLACE)
SENSOR - AIRBAG - FRONT - CENTER (REMOVE AND REPLACE)
SENSOR - AIRBAG - FRONT - LH (REMOVE AND REPLACE)
21 - INFOTAINMENT
2105 - TOUCHSCREEN
TOUCHSCREEN (REMOVE AND REPLACE)
2115 - CAR COMPUTER
CAR COMPUTER (REMOVE AND REPLACE)
CONNECTIVITY BOARD - CAR COMPUTER (REMOVE AND REPLACE)
SD CARD - CAR COMPUTER (REMOVE AND REPLACE)
SIM CARD - CAR COMPUTER (REMOVE AND REPLACE)
2121 - AUDIO SYSTEM - SPEAKERS SUBWOOFER AMPLIFIER
AMPLIFIER - AUDIO - EXTERNAL (REMOVE AND REPLACE)
SPEAKER - DASH - CENTER (REMOVE AND REPLACE)
SPEAKER - DASH - LH (REMOVE AND REPLACE)
SPEAKER - EMERGENCY (REMOVE AND REPLACE)
SPEAKER - FRONT DOOR - LH (REMOVE AND REPLACE)
SPEAKER - PARCEL SHELF - LH (REMOVE AND REPLACE)
SUBWOOFER (REMOVE AND REPLACE)
TWEETER - DASH (REMOVE AND REPLACE)
TWEETER - FRONT DOOR - LH (REMOVE AND REPLACE)
2125 - AUDIO SYSTEM - BLUETOOTH
MICROPHONE - BLUETOOTH (REMOVE AND REPLACE)
2126 - AUDIO SYSTEM - USB MEDIA PORT
USB HUB - CENTER CONSOLE - FRONT (REMOVE AND REPLACE)
USB HUB - CENTER CONSOLE - REAR (REMOVE AND REPLACE)
2130 - ANTENNA - FM HD RADIO
AMPLIFIER - ANTENNA - FM (REMOVE AND REPLACE)
TUNER - FM / HD (REMOVE AND REPLACE)
2131 - ANTENNA - SATELLITE RADIO
2132 - ANTENNA - GPS
ANTENNA - GPS (REMOVE AND REPLACE)
2133 - ANTENNA - WI-FI
ANTENNA - WI-FI (REMOVE AND REPLACE)
30 - CHASSIS
3001 - CHASSIS AND SUBFRAMES
ISOLATOR - MOTOR MOUNT - FRONT - LH (REMOVE AND REPLACE)
SUBFRAME ASSEMBLY - FRONT (DUAL MOTOR) (REMOVE AND INSTALL)
SUBFRAME ASSEMBLY - FRONT (DUAL MOTOR) (REMOVE AND REPLACE)
SUBFRAME ASSEMBLY - FRONT (RWD) (REMOVE AND INSTALL)
SUBFRAME ASSEMBLY - FRONT (RWD) (REMOVE AND REPLACE)
SUBFRAME ASSEMBLY - REAR (REMOVE AND INSTALL)
SUBFRAME ASSEMBLY - REAR (REMOVE AND REPLACE)
31 - SUSPENSION
3100 - ADJUSTMENT
FOUR WHEEL ALIGNMENT (CHECK)
FOUR WHEEL ALIGNMENT (CHECK AND ADJUST)
3101 - FRONT SUSPENSION (INCLUDING HUBS)
FRONT UPPER CONTROL ARM (FUCA) MOUNT - LH (REMOVE AND REPLACE)
CONTROL ARM - UPPER - FRONT - LH (REMOVE AND REPLACE)
HUB - FRONT - LH (DUAL MOTOR) (REMOVE AND REPLACE)
HUB - FRONT - LH (RWD) (REMOVE AND REPLACE)
KNUCKLE - SUSPENSION - FRONT - LH (DUAL MOTOR) (REMOVE AND REPLACE)
KNUCKLE - SUSPENSION - FRONT - LH (RWD) (REMOVE AND REPLACE)
LINK - COMPLIANCE - LOWER - FRONT - LH (REMOVE AND REPLACE)
LINK - LATERAL - LOWER - FRONT - LH (REMOVE AND REPLACE)
LINK - STABILIZER BAR - FRONT - LH (REMOVE AND REPLACE)
STABILIZER BAR - FRONT (REMOVE AND REPLACE)
SUSPENSION - FRONT (CHECK TORQUE)
3103 - REAR SUSPENSION (INCLUDING HUBS)
COVER - REAR SUSPENSION - LH (REMOVE AND REPLACE)
DROP LINK - STABILIZER BAR - REAR - LH (REMOVE AND REPLACE)
HUB - REAR - LH (REMOVE AND REPLACE)
KNUCKLE - SUSPENSION - REAR - LH (REMOVE AND REPLACE)
LINK - AFT - LOWER - REAR - LH (REMOVE AND REPLACE)
LINK - FORE - LOWER - REAR - LH (REMOVE AND REPLACE)
LINK - FORE - UPPER - REAR - LH (REMOVE AND REPLACE)
STABILIZER BAR - REAR (REMOVE AND REPLACE)
SUSPENSION - REAR (CHECK TORQUE)
TOE LINK - REAR - LH (REMOVE AND REPLACE)
3115 - COIL SUSPENSION SYSTEM
DAMPER - REAR - LH (COIL SUSPENSION) (REMOVE AND REPLACE)
SPRING - REAR SUSPENSION - LH (REMOVE AND REPLACE)
SPRING AND DAMPER ASSEMBLY - FRONT - LH (REMOVE AND REPLACE)
32 - STEERING
3201 - STEERING RACK AND LOWER COLUMN
MODULE - STEERING COLUMN CONTROL (REMOVE AND REPLACE)
STEERING RACK (DUAL MOTOR) (REMOVE AND REPLACE)
STEERING RACK (RWD) (REMOVE AND REPLACE)
TIE ROD END - LH (REMOVE AND REPLACE)
3205 - UPPER COLUMN STEERING WHEEL STEERING LOCK
STEERING COLUMN (REMOVE AND REPLACE)
STEERING WHEEL (REMOVE AND INSTALL)
STEERING WHEEL (REMOVE AND REPLACE)
33 - BRAKES
TORQUE SPECIFICATIONS - BRAKES
3301 - BRAKE DISCS AND CALIPERS
BRAKE CALIPER - FRONT - LH (REMOVE AND REPLACE)
BRAKE CALIPER - REAR - LH (REMOVE AND REPLACE)
BRAKE PADS - BURNISHING
BRAKE PAD KIT - FRONT (BASE BRAKES) (REMOVE AND REPLACE)
BRAKE PAD KIT - FRONT (SPORT BRAKES) (REMOVE AND REPLACE)
BRAKE PAD KIT - REAR (BASE BRAKES) (REMOVE AND REPLACE)
BRAKE PAD KIT - REAR (SPORT BRAKES) (REMOVE AND REPLACE)
BRAKE ROTOR - FRONT - LH (REMOVE AND REPLACE)
BRAKE ROTOR - REAR - LH (REMOVE AND REPLACE)
SHIELD - DUST - BRAKE - FRONT - LH (REMOVE AND REPLACE)
SHIELD - DUST - BRAKE - REAR - LH (REMOVE AND REPLACE)
SHIELD - DUST - BRAKE - REAR - LH AND RH (RETROFIT)
3303 - BRAKE PIPES AND HOSES
BRAKE FLUID BLEED - ONE CALIPER
BRAKE FLUID BLEED / FLUSH
BRAKE FLUID CHECK
BRAKE HOSE - FLEXIBLE - FRONT - LH (REMOVE AND REPLACE)
BRAKE HOSE - FLEXIBLE - REAR - LH (REMOVE AND REPLACE)
BRAKE LINES - 4 TUBE BUNDLE - ABS TO WHEELS (REMOVE AND REPLACE)
BRAKE LINES - LH SILL (REMOVE AND REPLACE)
BRAKE LINES - MASTER CYLINDER TO ABS (REMOVE AND REPLACE)
BRAKE LINES - REAR - LH TO SILL (REMOVE AND REPLACE)
BRAKE LINES - REAR - RH TO SILL (REMOVE AND REPLACE)
3305 - PARKING BRAKE
PARKING BRAKE - CALIPER - REAR - LH (RELEASE)
3310 - ABS TRACTION AND STABILITY CONTROL
ABS MODULATOR (REMOVE AND REPLACE)
SENSOR - WHEEL SPEED - ABS - FRONT - LH (REMOVE AND REPLACE)
SENSOR - WHEEL SPEED - ABS - REAR - LH (REMOVE AND REPLACE)
3320 - BRAKE BOOSTER
BOOSTER - BRAKE - ELECTROMECHANICAL (LHD) (REMOVE AND REPLACE)
MASTER CYLINDER AND RESERVOIR ASSEMBLY (REMOVE AND REPLACE)
3325 - BRAKE PEDAL
BRAKE PEDAL (REMOVE AND REPLACE)
SWITCH - BRAKE LIGHT (REMOVE AND REPLACE)
34 - WHEEL AND TIRES
3401 - WHEELS
CAP - WHEEL (REMOVE AND REPLACE)
WHEEL (REMOVE AND INSTALL)
3402 - TIRES
TIRE - FRONT - LH (DISMOUNT AND MOUNT)
TIRE - FRONT - LH (REBALANCE)
TIRE - FRONT - LH (REPAIR)
TIRE ROTATION
3404 - TIRE PRESSURE MONITORING SYSTEM (TPMS)
MODULE - TPMS (REMOVE AND REPLACE)
MODULE - TPMS (SENSOR ID LEARN)
SENSOR - TPMS (REMOVE AND REPLACE)
39 - FRONT DRIVE UNIT
3901 - FRONT DRIVE UNIT ASSEMBLY
BUSHING – FRONT DRIVE UNIT – RH (REMOVE AND REPLACE)
DRIVE UNIT - FRONT (REMOVE AND INSTALL)
DRIVE UNIT - FRONT (REMOVE AND REPLACE)
GROUND STRAP - FRONT DRIVE UNIT (REMOVE AND REPLACE)
MOUNT - FRONT DRIVE UNIT - LH (REMOVE AND REPLACE)
3920 - FRONT DRIVE INVERTER
HOSE - INVERTER INLET - FRONT DRIVE UNIT (REMOVE AND REPLACE)
HOSE - INVERTER TO HEAT EXCHANGER - FRONT DRIVE UNIT (REMOVE AND REPLACE)
3930 - FRONT GEARBOX AND HALFSHAFTS
BREATHER - FRONT DRIVE UNIT (REMOVE AND REPLACE)
BUSHING - GEARBOX - FRONT DRIVE UNIT (REMOVE AND REPLACE)
FILTER - OIL - FRONT DRIVE UNIT (REMOVE AND REPLACE)
GEARBOX FLUID - FRONT DRIVE UNIT (DRAIN AND REFILL)
HALFSHAFT - FRONT DRIVE UNIT - LH (REMOVE AND REPLACE)
HEAT EXCHANGER - FRONT DRIVE UNIT (REMOVE AND REPLACE)
HOSE - HEAT EXCHANGER TO SUPERBOTTLE - FRONT DRIVE UNIT (REMOVE AND REPLACE)
OIL PUMP - FRONT DRIVE UNIT (REMOVE AND REPLACE)
OIL SCREEN - FRONT DRIVE UNIT (REMOVE AND REPLACE)
SEAL - OIL - DIFFERENTIAL TO HALFSHAFT - FRONT DRIVE UNIT - LH (REMOVE AND REPLACE)
40 - REAR DRIVE UNIT
4001 - REAR DRIVE UNIT ASSEMBLY
BUSHING - REAR DRIVE UNIT - REAR (REMOVE AND REPLACE)
BUSHING - REAR DRIVE UNIT - RH (REMOVE AND REPLACE)
FLUID COUPLING (55 DEGREES) - REAR DRIVE UNIT (REMOVE AND REPLACE)
FLUID COUPLING (STRAIGHT) - REAR DRIVE UNIT (REMOVE AND REPLACE)
DRIVE UNIT - REAR (REMOVE AND INSTALL)
DRIVE UNIT - REAR (REMOVE AND REPLACE)
MOUNT - REAR DRIVE UNIT - LH (REMOVE AND REPLACE)
4010 - REAR MOTOR
MOTOR ASSEMBLY - REAR (REMOVE AND REPLACE)
SENSOR - REAR MOTOR - SPEED (REMOVE AND REPLACE)
4020 - REAR DRIVE INVERTER
HV HEADER - INVERTER - REAR DRIVE UNIT (REMOVE AND REPLACE)
INVERTER AIR LEAK TEST
INVERTER COOLANT LEAK TEST
INVERTER - REAR DRIVE UNIT (REMOVE AND INSTALL)
INVERTER - REAR DRIVE UNIT (REMOVE AND REPLACE)
POWERTRAIN COOLANT (DRAIN AND REFILL)
4030 - REAR GEARBOX AND HALFSHAFTS
BREATHER - REAR DRIVE UNIT (REMOVE AND REPLACE)
FILTER - OIL - REAR DRIVE UNIT (REMOVE AND REPLACE)
GEARBOX - REAR DRIVE UNIT (REMOVE AND REPLACE)
GEARBOX FLUID - REAR DRIVE UNIT (DRAIN AND REFILL)
HALFSHAFT - REAR DRIVE UNIT - LH (REMOVE AND REPLACE)
HEAT EXCHANGER - REAR DRIVE UNIT (REMOVE AND REPLACE)
OIL PUMP - REAR DRIVE UNIT (REMOVE AND REPLACE)
OIL SCREEN - REAR DRIVE UNIT (REMOVE AND REPLACE)
SEAL - OIL - DIFFERENTIAL TO HALFSHAFT - REAR DRIVE UNIT - LH (REMOVE AND REPLACE)
44 - HIGH VOLTAGE SYSTEM
4401 - CHARGE SYSTEM INLET
CARRIER ASSEMBLY - CHARGE PORT (REMOVE AND REPLACE)
CHARGE PORT - MANUAL RELEASE OF CABLE
CHARGE PORT VOLTAGE CHECK
DEADFRONTS - PIN - CHARGE PORT (NA) (REMOVE AND REPLACE)
DOOR AND HINGE COVER - CHARGE PORT (REMOVE AND REPLACE)
DOOR ASSEMBLY - CHARGE PORT (NA) (REMOVE AND REPLACE)
DOOR ASSEMBLY - CHARGE PORT (CHINA) (REMOVE AND REPLACE)
ECU - CHARGE PORT (REMOVE AND REPLACE)
LATCH ACTUATOR - CHARGE PORT (REMOVE AND REPLACE)
4450 - HV HARNESSES
HARNESS - CHARGE PORT TO HV BATTERY (SINGLE-PHASE) (REMOVE AND REPLACE)
HARNESS - CHARGE PORT TO HV BATTERY (THREE-PHASE) (REMOVE AND REPLACE)
HARNESS - HV BATTERY TO FRONT DRIVE UNIT (REMOVE AND REPLACE)
HARNESS - HV BATTERY TO PTC HEATER AND A/C COMPRESSOR (DUAL MOTOR) (REMOVE AND REPLACE)
HARNESS - HV BATTERY TO PTC HEATER AND A/C COMPRESSOR (RWD) (REMOVE AND REPLACE)
HARNESS - HV BATTERY TO REAR DRIVE UNIT (REMOVE AND REPLACE)
50 - EXTERNAL CHARGING CONNECTORS
5001 - MOBILE CONNECTOR
FIRMWARE UPDATE - CHADEMO CHARGING ADAPTER
MODEL 3 SERVICE MANUAL
GENERAL INFORMATION
INTRODUCTION
HOW TO USE THIS MANUAL
REPAIRS AND REPLACEMENTS
WARRANTY SERVICE REGIONS
ABBREVIATIONS AND SYMBOLS
BEST PRACTICES
ELECTRICAL PRECAUTIONS
GENERAL PRECAUTIONS
ENVIRONMENTAL PRECAUTIONS
GENERAL FITTING INSTRUCTIONS
OIL SEALS
LOCKING DEVICES
FLEXIBLE PIPES AND HOSES
WHEELS AND TIRES
AIRBAG AND SUPPLEMENTARY RESTRAINT SYSTEM (SRS) PRECAUTIONS
AIRBAG AND SUPPLEMENTARY RESTRAINT SYSTEM (SRS) COMPONENT REPLACEMENT POLICY
AIR CONDITIONING SYSTEM PRECAUTIONS
CHARGING
GENERAL
TECHNICAL DATA
MOTORS
SUSPENSION
WHEEL ALIGNMENT
BRAKES
WHEELS
TIRE PRESSURES
ELECTRICAL
IDENTIFICATION NUMBERS
VEHICLE IDENTIFICATION NUMBER (VIN)
SERIAL NUMBERS
DRIVE UNIT NUMBER
MANUFACTURING CERTIFICATION LABEL
VEHICLE PAINT CODES
FLUIDS AND CAPACITIES
00 - INSPECTION AND SERVICE
0001 - MAINTENANCE SERVICE
MAINTENANCE SERVICE AND INTERVALS
10 - BODY
1000 - VEHICLE LIFTING
RAISE VEHICLE - 2 POST LIFT
RAISE VEHICLE - 4 POST LIFT
1001 - BUMPER / FASCIA
ANKLE CATCHER (REMOVE AND REPLACE)
BRACKET - FASCIA SIDE TO FENDER - LH (REMOVE AND REPLACE)
BRACKET - REAR - CENTER (REMOVE AND REPLACE)
BRACKET - REAR WING - LH (REMOVE AND REPLACE)
BRACKET - TAILLIGHT - LH (REMOVE AND REPLACE)
BUMPER - FRONT (REMOVE AND REPLACE)
BUMPER - REAR (REMOVE AND REPLACE)
COVER - TOW HOOK (REMOVE AND REPLACE)
CRUSH CAN - FRONT - LH (REMOVE AND REPLACE)
FASCIA - FRONT (REMOVE AND INSTALL)
FASCIA - FRONT (REMOVE AND REPLACE)
FASCIA - REAR (REMOVE AND INSTALL)
FASCIA - REAR - LOWER (REMOVE AND REPLACE)
FASCIA - REAR - UPPER (REMOVE AND REPLACE)
GRILLE - FASCIA - FRONT (REMOVE AND REPLACE)
VALANCE - FRONT FASCIA (REMOVE AND REPLACE)
1010 - BODY PANELS
BRACE - SHOCK TOWER (REMOVE AND REPLACE)
BRACKET - CRASH CAN - LH (REMOVE AND REPLACE)
CARRIER - FRONT END (REMOVE AND REPLACE)
DOOR - FRONT - LH (REMOVE AND INSTALL)
DOOR - FRONT - LH (REMOVE AND REPLACE)
DOOR - REAR - LH (REMOVE AND INSTALL)
DOOR - REAR - LH (REMOVE AND REPLACE)
FENDER ASSEMBLY - FRONT - LH (REMOVE AND REPLACE)
HOOD (REMOVE AND INSTALL)
HOOD (REMOVE AND REPLACE)
TRUNK (REMOVE AND INSTALL)
TRUNK (REMOVE AND REPLACE)
1020 - WINDSHIELD AND BODY GLASS
GLASS - BACKLIGHT (REMOVE AND REPLACE)
GLASS - BODY - REAR QUARTER - LH (REMOVE AND REPLACE)
GLASS - ROOF - FIXED (REMOVE AND REPLACE)
SENSOR - RELATIVE HUMIDITY AND TEMPERATURE (REMOVE AND REPLACE)
WINDSHIELD (REMOVE AND INSTALL)
WINDSHIELD (REMOVE AND REPLACE)
1030 - PAINT
PAINT DEFECT RECTIFICATION
11 - CLOSURES
1133 - CLOSURE ASSIST MECHANISMS AND HINGES
GAS STRUT - HOOD - LH (REMOVE AND REPLACE)
GAS STRUT - TRUNK - LH (REMOVE AND REPLACE)
HINGE - HOOD - LH (REMOVE AND REPLACE)
HINGE - TRUNK - LH (REMOVE AND REPLACE)
1135 - LATCHES STRIKERS AND PINCH SENSORS
ACTUATOR - LATCH - HOOD - PRIMARY (REMOVE AND REPLACE)
ACTUATOR - LATCH - HOOD - SECONDARY (REMOVE AND REPLACE)
LATCH - DOOR - FRONT - LH (REMOVE AND REPLACE)
LATCH - DOOR - REAR - LH (REMOVE AND REPLACE)
LATCH - HOOD (REMOVE AND REPLACE)
LATCH - TRUNK (REMOVE AND REPLACE)
MANUAL RELEASE - DOOR - REAR - LH (ACTUATE)
STRIKER - DOOR - FRONT - LH (REMOVE AND REPLACE)
STRIKER - DOOR - REAR - LH (REMOVE AND REPLACE)
STRIKER - HOOD (REMOVE AND REPLACE)
STRIKER - TRUNK (REMOVE AND REPLACE)
SWITCH - EXTERIOR RELEASE - TRUNK (REMOVE AND REPLACE)
1145 - EXTERIOR DOOR HANDLES
HALL SENSOR - EXTERIOR RELEASE - DOOR - FRONT - LH (REMOVE AND REPLACE)
HALL SENSOR - EXTERIOR RELEASE - DOOR - REAR - LH (REMOVE AND REPLACE)
HANDLE - EXTERIOR RELEASE - DOOR - FRONT - LH (ADJUST)
HANDLE - EXTERIOR RELEASE - DOOR - FRONT - LH (REMOVE AND REPLACE)
HANDLE - EXTERIOR RELEASE - DOOR - REAR - LH (ADJUST)
HANDLE - EXTERIOR RELEASE - DOOR - REAR - LH (REMOVE AND REPLACE)
1150 - DOOR GLASS AND REGULATORS
GLASS - DOOR - LH - FRONT (ADJUST)
GLASS - DOOR - LH - FRONT (REMOVE AND REPLACE)
GLASS - DOOR - LH - REAR (ADJUST)
GLASS - DOOR - LH - REAR (REMOVE AND REPLACE)
SWITCH - WINDOW - DRIVER (REMOVE AND REPLACE)
SWITCH - WINDOW - FRONT PASSENGER (REMOVE AND REPLACE)
SWITCH - WINDOW - REAR (REMOVE AND REPLACE)
WINDOW MOTOR / REGULATOR ASSEMBLY - FRONT - LH (REMOVE AND REPLACE)
WINDOW MOTOR / REGULATOR ASSEMBLY - REAR - LH (REMOVE AND REPLACE)
WINDOW REGULATOR - FRONT - LH (RECALIBRATE)
WINDOW REGULATOR - REAR - LH (RECALIBRATE)
1170 - SEALS BODY CLOSURES
CLOSEOUT PANEL - DOOR - FRONT - LH (REMOVE AND INSTALL)
SEAL - BODY - SIDE - FRONT - PRIMARY - LH (REMOVE AND REPLACE)
SEAL - BODY - SIDE - REAR - PRIMARY - LH (REMOVE AND REPLACE)
SEAL - GLASS RUN - FRONT DOOR - LH (REMOVE AND REPLACE)
SEAL - HOOD (REMOVE AND REPLACE)
SEAL - INNER BELT - FRONT DOOR - LH (REMOVE AND REPLACE)
SEAL - INNER BELT - REAR DOOR - LH (REMOVE AND REPLACE)
SEAL - OUTER BELT - FRONT DOOR - LH (REMOVE AND REPLACE)
SEAL - OUTER BELT - REAR DOOR - LH (REMOVE AND REPLACE)
SEAL - SECONDARY - FRONT DOOR - LH (REMOVE AND REPLACE)
SEAL - SECONDARY - REAR DOOR - LH (REMOVE AND REPLACE)
SEAL - TRUNK (REMOVE AND REPLACE)
12 - EXTERIOR FITTINGS
1201 - WHEEL ARCH LINERS
WHEEL ARCH LINER - FRONT - LH (REMOVE AND REPLACE)
WHEEL ARCH LINER - REAR - LH (REMOVE AND REPLACE)
1203 - UNDERTRAY AND DIFFUSER
DIFFUSER - REAR FASCIA (REMOVE AND REPLACE)
PANEL - AERO SHIELD - FRONT (REMOVE AND REPLACE)
PANEL - AERO SHIELD - MID (REMOVE AND REPLACE)
1205 - BADGES AND FILMS
REAR LETTERING (RETROFIT)
TESLA BADGE - FRONT (REMOVE AND REPLACE)
TESLA BADGE - REAR (REMOVE AND REPLACE)
1207 - LICENSE PLATE MOUNTINGS
BRACKET - LICENSE PLATE - FRONT (EMEA) (RETROFIT USING JIG)
BRACKET - LICENSE PLATE - FRONT (EMEA) (RETROFIT USING TEMPLATE)
BRACKET - LICENSE PLATE - FRONT (REMOVE AND REPLACE)
BRACKET - LICENSE PLATE - FRONT (NA) (RETROFIT)
BRACKET - LICENSE PLATE - REAR (EMEA) (REMOVE AND REPLACE)
1209 - EXTERIOR MIRRORS
GLASS - DOOR MIRROR - LH (REMOVE AND REPLACE)
MIRROR - DOOR - LH (REMOVE AND REPLACE)
SKULL CAP - DOOR MIRROR - LH (REMOVE AND REPLACE)
1220 - EXTERIOR TRIM
APPLIQUE - B-PILLAR - LH (REMOVE AND REPLACE)
BRIGHTWORK - UPPER - LH (REMOVE AND REPLACE)
COVER - ROCKER PANEL - LOWER - LH (REMOVE AND REPLACE)
1222 - SPOILER
SPOILER - REAR (RETROFIT USING JIG)
SPOILER - REAR (RETROFIT USING TAPE)
1225 - UNDERHOOD TRIM
COVER - SHOCK TOWER - LH (REMOVE AND REPLACE)
PANEL - COWL SCREEN (REMOVE AND REPLACE)
UNDERHOOD APRON - REAR (REMOVE AND REPLACE)
13 - SEATS
1301 - FRONT SEAT TRACKS AND MOTORS
COVER - FRONT - SEAT TRACK - 1ST ROW SEAT (REMOVE AND REPLACE)
COVER - REAR - SEAT TRACK - 1ST ROW SEAT (REMOVE AND REPLACE)
MOTOR - RECLINER - BACKREST - DRIVER SEAT (REMOVE AND REPLACE)
MOTOR - SEAT HEIGHT - DRIVER SEAT (REMOVE AND REPLACE)
MOTOR - SEAT TILT - DRIVER SEAT (REMOVE AND REPLACE)
SWITCH - BACK REST AND CUSHION ADJUST - DRIVER SEAT (REMOVE AND REPLACE)
1304 - FRONT SEAT ASSEMBLIES AND HARDWARE
LUMBAR SUPPORT - BACKREST - DRIVER SEAT (REMOVE AND REPLACE)
SHELL - SEAT BACK - DRIVER (REMOVE AND REPLACE)
SEAT - DRIVER (REMOVE AND REPLACE)
TRIM - HEADREST - DRIVER (REMOVE AND REPLACE)
1305 - 2ND ROW SEAT ASSEMBLIES AND HARDWARE
ARMREST - 2ND ROW (REMOVE AND REPLACE)
BEZEL - HANDLE - SEAT BACK - 2ND ROW - LH (REMOVE AND REPLACE)
BOLSTER - SIDE - SEAT - 2ND ROW - LH (REMOVE AND REPLACE)
BRACKET - HINGE - SEAT BACK - 2ND ROW - LH (REMOVE AND REPLACE)
CAP - PENTHOUSE 12V (REMOVE AND REPLACE)
CAP - PENTHOUSE HV (REMOVE AND REPLACE)
CLOSEOUT - ARMREST - 2ND ROW (REMOVE AND REPLACE)
FRAME - SEAT BACK - 2ND ROW - LH (REMOVE AND REPLACE)
HANDLE - SEAT BACK - 2ND ROW - LH (REMOVE AND REPLACE)
HEADREST - 2ND ROW - CENTER (REMOVE AND REPLACE)
LATCH - SEAT BACK - 2ND ROW - LH (REMOVE AND REPLACE)
PIVOT SLEEVE - SEAT BACK - 2ND ROW - LH (REMOVE AND REPLACE)
RAIL - 2ND ROW - INNER - LH (REMOVE AND REPLACE)
RAIL - 2ND ROW - OUTER - LH (REMOVE AND REPLACE)
SEAT BACK - 2ND ROW - LH (REMOVE AND INSTALL)
SEAT BACK - 2ND ROW - RH (REMOVE AND INSTALL)
SEAT CUSHION - LOWER - 2ND ROW (REMOVE AND REPLACE)
STRIKER - SEAT BACK - 2ND ROW - LH (REMOVE AND REPLACE)
STRIKER - SEAT BACK - 2ND ROW - RH (REMOVE AND REPLACE)
1307 - FRONT SEAT COVERS PADS AND TRIMS
COVER - OUTER SIDE - DRIVER SEAT (REMOVE AND INSTALL)
FOAM - BACKREST - DRIVER SEAT (REMOVE AND REPLACE)
FOAM - CUSHION - DRIVER SEAT (REMOVE AND REPLACE)
1308 - 2ND ROW SEAT COVERS PADS AND TRIMS
COVER - SEAT BACK - 2ND ROW SEAT - RH (REMOVE AND REPLACE)
CUP HOLDER - 2ND ROW (REMOVE AND REPLACE)
14 - INSTRUMENT PANEL
1405 - INSTRUMENT PANEL
BEAM - CROSS CAR (REMOVE AND REPLACE)
COVER - AIRBAG - KNEE - DRIVER (REMOVE AND REPLACE)
COVER - AIRBAG - KNEE - FRONT PASSENGER (REMOVE AND REPLACE)
COVER - FOOTWELL - DRIVER (REMOVE AND REPLACE)
COVER - FOOTWELL - PASSENGER (LHD) (REMOVE AND REPLACE)
DAMPER - GLOVE BOX (REMOVE AND REPLACE)
DECOR TRIM - INSTRUMENT PANEL - MAIN (REMOVE AND REPLACE)
END CAP - INSTRUMENT PANEL - LH (REMOVE AND REPLACE)
FINISHER - VENT (REMOVE AND REPLACE)
GLOVE BOX (LHD) (REMOVE AND REPLACE)
GRILLE - SPEAKER - INSTRUMENT PANEL (REMOVE AND REPLACE)
HOUSING - CENTER DISPLAY (REMOVE AND REPLACE)
IP CARRIER (REMOVE AND INSTALL)
IP CARRIER (REMOVE AND REPLACE)
VENT - FRONT - LH (REMOVE AND REPLACE)
VENT - FRONT - RH (REMOVE AND REPLACE)
SOLENOID - GLOVE BOX (REMOVE AND REPLACE)
END CAP - AIR WAVE - LH (REMOVE AND REPLACE)
15 - INTERIOR TRIM
1505 - INTERIOR MIRROR AND SUN VISORS
CHECK BASE - SUN VISOR - DRIVER (REMOVE AND REPLACE)
SUN VISOR - DRIVER (REMOVE AND REPLACE)
MIRROR - REAR VIEW (REMOVE AND REPLACE)
QUAD CAMERA COVER - LOWER (REMOVE AND REPLACE)
QUAD CAMERA COVER - UPPER (REMOVE AND REPLACE)
1511 - TRUNK TRIM
GARNISH - TRUNK (REMOVE AND REPLACE)
TRIM - LID - TRUNK (REMOVE AND REPLACE)
1513 - DOOR TRIM
PANEL - DOOR TRIM - FRONT - LH (REMOVE AND INSTALL)
PANEL - DOOR TRIM - FRONT - LH (REMOVE AND REPLACE)
PANEL - DOOR TRIM - REAR - LH (REMOVE AND INSTALL)
PANEL - DOOR TRIM - REAR - LH (REMOVE AND REPLACE)
1518 - PILLAR AND SILL TRIM
FOOTREST - DRIVER (REMOVE AND REPLACE)
TRIM - A-PILLAR - LOWER - LH (REMOVE AND REPLACE)
TRIM - A-PILLAR - MIDDLE - LH (REMOVE AND REPLACE)
TRIM - A-PILLAR - UPPER - LH (REMOVE AND REPLACE)
TRIM - B-PILLAR - LOWER - LH (REMOVE AND REPLACE)
TRIM - B-PILLAR - UPPER - LH (REMOVE AND REPLACE)
TRIM - C-PILLAR - REAR - LH (REMOVE AND REPLACE)
TRIM - C-PILLAR - UPPER - LH (REMOVE AND REPLACE)
TRIM - SIDE RAIL - LH (REMOVE AND INSTALL)
TRIM - SIDE RAIL - LH (REMOVE AND REPLACE)
TRIM - SILL PANEL - REAR - LH (REMOVE AND REPLACE)
1519 - CENTER CONSOLE
ARMREST - CENTER CONSOLE (REMOVE AND REPLACE)
CARPET - SIDE PANEL - CENTER CONSOLE - LH (REMOVE AND REPLACE)
CENTER CONSOLE (REMOVE AND INSTALL)
CENTER CONSOLE (REMOVE AND REPLACE)
CUP HOLDER (REMOVE AND REPLACE)
DECOR TRIM - CENTER CONSOLE (REMOVE AND REPLACE)
END PANEL - CENTER CONSOLE (REMOVE AND REPLACE)
INSERT - FRONT BIN - CENTER CONSOLE (REMOVE AND REPLACE)
PANEL - AIR VENT - CENTER CONSOLE (REMOVE AND REPLACE)
PANEL - LOWER REAR - CENTER CONSOLE (REMOVE AND REPLACE)
PHONE TRAY - CENTER CONSOLE (REMOVE AND REPLACE)
1520 - HEADLINER
COAT HOOK - REAR - LH (REMOVE AND REPLACE)
HEADLINER (REMOVE AND INSTALL)
HEADLINER (REMOVE AND REPLACE)
OVERHEAD CONSOLE - FRONT (REMOVE AND REPLACE)
OVERHEAD CONSOLE - REAR (REMOVE AND REPLACE)
1524 - LUGGAGE COMPARTMENT TRIM
COVER - HOOD LATCH (REMOVE AND REPLACE)
SWITCH - CHILD SAFETY - UNDERHOOD STORAGE AREA (REMOVE AND REPLACE)
TRIM - FLOOR - TRUNK (REMOVE AND REPLACE)
TRIM - SIDE - TRUNK - LH (REMOVE AND REPLACE)
TRIM - SIDE - TRUNK - RH (REMOVE AND REPLACE)
TRIM - SILL - TRUNK (REMOVE AND REPLACE)
TRIM - PACKAGE TRAY (REMOVE AND INSTALL)
UNDERHOOD STORAGE UNIT (REMOVE AND REPLACE)
1530 - CARPETING AND MATS
CARPET - FRONT - LH (REMOVE AND REPLACE)
CARPET - FRONT - RH (REMOVE AND REPLACE)
OBSOLETE - CARPET - INTERIOR COMPLETE (REMOVE AND REPLACE)
CARPET - REAR (REMOVE AND REPLACE)
CARPET - REAR TRUNK (REMOVE AND REPLACE)
CARPET - UNDERHOOD STORAGE (REMOVE AND INSTALL)
16 - BATTERY SYSTEM
1601 - HV BATTERY ASSEMBLY
HV BATTERY (RWD) (REMOVE AND INSTALL)
HV BATTERY (RWD) (REMOVE AND REPLACE)
HV BATTERY (DUAL MOTOR) (REMOVE AND INSTALL)
HV BATTERY (DUAL MOTOR) (REMOVE AND REPLACE)
1610 - HV BATTERY ENCLOSURE
BREATHERS - HV BATTERY (REMOVE AND REPLACE)
COVER - HV PROBE - HV BATTERY (REMOVE AND REPLACE)
COVER - PENTHOUSE (REMOVE AND REPLACE)
FLOOD PORTS - 2ND GENERATION (REMOVE AND REPLACE)
FLOOD PORTS - 2ND GENERATION (RETROFIT)
GASKET - COVER - HV BATTERY (REMOVE AND REPLACE)
HV BATTERY AIR LEAK TEST
PENTHOUSE AIR LEAK TEST
PLATTER ENCLOSURE AIR LEAK TEST
SKI - CENTER RAIL - HV BATTERY (RWD) (REMOVE AND REPLACE)
SKI - CENTER RAIL - HV BATTERY (DUAL MOTOR) (REMOVE AND REPLACE)
SKID PLATE - HV BATTERY - FRONT (REMOVE AND REPLACE)
SKID PLATE - HV BATTERY - REAR (REMOVE AND REPLACE)
VENT ASSEMBLY - HV BATTERY - LH (REMOVE AND REPLACE)
VENT ASSEMBLY - HV BATTERY - RH (REMOVE AND REPLACE)
1620 - HV BATTERY COOLING SYSTEM
COOLANT - HV BATTERY (DRAIN AND REFILL)
PENTHOUSE COOLANT (DRAIN AND REFILL)
PENTHOUSE COOLANT LEAK TEST
PLATTER ENCLOSURE COOLANT (DRAIN AND REFILL)
PLATTER ENCLOSURE COOLANT LEAK TEST
TUBE - INPUT - COOLANT - POWER CONVERSION SYSTEM (REMOVE AND REPLACE)
TUBE - OUTPUT - COOLANT - POWER CONVERSION SYSTEM (REMOVE AND REPLACE)
1630 - HV BATTERY ELECTRICAL COMPONENTS
CONTACTOR - FAST CHARGE - HV BATTERY (REMOVE AND REPLACE)
CONTACTOR - NEGATIVE - HV BATTERY (REMOVE AND REPLACE)
CONTACTOR - POSITIVE - HV BATTERY (REMOVE AND REPLACE)
CONTROLLER - HIGH VOLTAGE (REMOVE AND REPLACE)
DC INPUT ASSEMBLY - HV BATTERY (REMOVE AND REPLACE)
FUSE - A/C COMPRESSOR - HV BATTERY (REMOVE AND REPLACE)
FUSE - CABIN HEATER - HV BATTERY (REMOVE AND REPLACE)
FUSE - POWER CONVERSION SYSTEM - HV BATTERY (REMOVE AND REPLACE)
GUIDE - PROBING - HV BATTERY (REMOVE AND REPLACE)
HARNESS - AC INLET - HV BATTERY (REMOVE AND REPLACE)
HARNESS - PENTHOUSE - HV BATTERY (REMOVE AND REPLACE)
HV BATTERY CONTACTOR SEIZE CHECK
HV HEADER - HV BATTERY (REMOVE AND REPLACE)
INSULATORS - HV BATTERY (INSTALL)
PASSTHROUGH - DCDC - 12V (REMOVE AND REPLACE)
POWER CONVERSION SYSTEM (REMOVE AND REPLACE)
PYROTECHNIC BATTERY DISCONNECT (REMOVE AND REPLACE)
SHUNT - HV BATTERY (REMOVE AND REPLACE)
17 - ELECTRICAL
1701 - 12V BATTERY AND FUSES
12V POWER (DISCONNECT AND CONNECT)
BATTERY - 12V (REMOVE AND REPLACE)
BEAM - 12V BATTERY (DUAL MOTOR) (REMOVE AND REPLACE)
BEAM - 12V BATTERY (RWD) (REMOVE AND REPLACE)
BRACKET - 12V BATTERY (DUAL MOTOR) (REMOVE AND REPLACE)
BRACKET - 12V BATTERY (RWD) (REMOVE AND REPLACE)
STRAP - 12V BATTERY (REMOVE AND REPLACE)
VEHICLE ELECTRICAL ISOLATION PROCEDURE
VENT HOSE - 12V BATTERY (REMOVE AND REPLACE)
1710 - HARNESSES
BUSBAR - DCDC GROUND (REMOVE AND REPLACE)
HARNESS - 12V BATTERY GROUND (REMOVE AND REPLACE)
HARNESS - 12V BATTERY POSITIVE (REMOVE AND REPLACE)
HARNESS - BODY - LH (REMOVE AND REPLACE)
HARNESS - BODY - RH (REMOVE AND REPLACE)
HARNESS - DOOR - FRONT - LH (REMOVE AND REPLACE)
HARNESS - DOOR - REAR - LH (REMOVE AND REPLACE)
HARNESS - DRIVE UNIT - FRONT (REMOVE AND REPLACE)
HARNESS - HEADLINER (REMOVE AND REPLACE)
HARNESS - INSTRUMENT PANEL (REMOVE AND REPLACE)
HARNESS - MAIN FRONT (REMOVE AND REPLACE)
HARNESS - SUBFRAME - REAR (REMOVE AND REPLACE)
HARNESS - THERMAL BEAM (REMOVE AND REPLACE)
HARNESS - TRUNK (REMOVE AND REPLACE)
HARNESS - WINDSHIELD (REMOVE AND REPLACE)
1715 - ELECTRONIC CONTROL MODULES
MODULE - BODY CONTROLLER - FRONT (DUAL MOTOR) (REMOVE AND REPLACE)
MODULE - BODY CONTROLLER - FRONT (RWD) (REMOVE AND REPLACE)
MODULE - BODY CONTROLLER - LH (REMOVE AND REPLACE)
MODULE - BODY CONTROLLER - RH (REMOVE AND REPLACE)
MODULE - HOMELINK TRANSMITTER (REMOVE AND REPLACE)
1720 - RADAR SENSORS
SENSOR - RADAR - FRONT (CALIBRATION)
SENSOR - RADAR - FRONT (REMOVE AND REPLACE)
1723 - FRONT CAMERAS
CAMERA - FORWARD FACING (REMOVE AND REPLACE)
CAMERA - FORWARD FACING (TARGET CALIBRATION)
1724 - INTERIOR CAMERA
CAMERA - OCCUPANT (REMOVE AND REPLACE)
1725 - REAR CAMERAS
CAMERA - REAR FACING (REMOVE AND REPLACE)
1727 - PARKING SENSORS
SENSOR - PARKING DISTANCE - FRONT - EACH (REMOVE AND REPLACE)
SENSOR - PARKING DISTANCE - REAR - EACH (REMOVE AND REPLACE)
1730 - INTERIOR SWITCHES
POWER SOCKET 12V - CENTER CONSOLE (REMOVE AND REPLACE)
SWITCH - STEERING WHEEL - LH (REMOVE AND REPLACE)
SWITCH - STEERING WHEEL - RH (REMOVE AND REPLACE)
1735 - INTERIOR LIGHTING
PUDDLE LIGHT - FRONT DOOR - LH (REMOVE AND REPLACE)
PUDDLE LIGHT - REAR DOOR - LH (REMOVE AND REPLACE)
1740 - EXTERIOR LIGHTS
ECU - HEADLIGHT (REMOVE AND REPLACE)
HEADLIGHTS - ADJUST - EMEA (TOOL METHOD)
HEADLIGHTS - ADJUST - EMEA (WALL METHOD)
HEADLIGHTS - ADJUST - NA (TOOL METHOD)
HEADLIGHTS - ADJUST - NA (WALL METHOD)
HEADLIGHT - LH (REMOVE AND REPLACE)
LIGHT - BRAKE - HIGH MOUNTED (REMOVE AND REPLACE)
LIGHT - FOG - FRONT (ADJUST)
LIGHT - FOG / REVERSE - REAR - LH (REMOVE AND REPLACE)
LIGHT - LICENSE PLATE (REMOVE AND REPLACE)
LIGHT - SIDE REPEATER - FRONT - LH (REMOVE AND REPLACE)
LIGHT - TURN SIGNAL / FOG - FRONT - LH (REMOVE AND REPLACE)
TAILLIGHT - LH (REMOVE AND REPLACE)
REFLEX LENS - REAR - RH (REMOVE AND REPLACE)
REFLECTOR - FASCIA - REAR - LH (REMOVE AND REPLACE)
1745 - KEYLESS ENTRY AND SECURITY
ANTENNA - BLUETOOTH PASSIVE ENTRY - FRONT (REMOVE AND REPLACE)
ANTENNA - BLUETOOTH PASSIVE ENTRY - REAR (REMOVE AND REPLACE)
KEY – PROGRAMMING (WITH AUTHENTICATED KEY PRESENT)
MODULE - BODY CONTROLLER - SECURITY (REMOVE AND REPLACE)
SIREN - BATTERY BACKED (REMOVE AND REPLACE)
1750 - WIPERS AND WASHERS
RESERVOIR - WINDSHIELD WASHER (REMOVE AND REPLACE)
WIPER MOTOR (REMOVE AND REPLACE)
WIPER ARMS (REMOVE AND REPLACE)
WIPER BLADES (ADJUST)
WIPER BLADES (REMOVE AND REPLACE)
1753 - HORNS
HORN - HIGH TONE (REMOVE AND REPLACE)
HORN - LOW TONE (REMOVE AND REPLACE)
1754 - PEDESTRIAN WARNING SPEAKER
SPEAKER - PEDESTRIAN WARNING (REMOVE AND REPLACE)
1755 - ACCELERATOR PEDAL
ACCELERATOR (REMOVE AND REPLACE)
18 - THERMAL MANAGEMENT
1810 - CABIN HVAC
ACTUATOR - BLEED - LH (REMOVE AND REPLACE)
ACTUATOR - INTAKE (REMOVE AND REPLACE)
ACTUATOR - LOWER MODE (REMOVE AND REPLACE)
ACTUATOR - UPPER MODE (REMOVE AND REPLACE)
ACTUATOR - VENT - LH (REMOVE AND REPLACE)
ACTUATOR - VENT - RH (REMOVE AND REPLACE)
AIR EXTRACTOR - LH (REMOVE AND REPLACE)
DUCT - AIR WAVE - LH (REMOVE AND REPLACE)
DUCT - AIR WAVE - RH (REMOVE AND REPLACE)
DUCT - CABIN INTAKE (REMOVE AND REPLACE)
DUCT - FOOTWELL - LH (REMOVE AND REPLACE)
DUCT - FOOTWELL - RH (REMOVE AND REPLACE)
DUCT - HVAC PLENUM - INNER (REMOVE AND REPLACE)
DUCT - HVAC PLENUM - OUTER (REMOVE AND REPLACE)
FILTER - CABIN (REMOVE AND REPLACE)
HEATER - PTC (REMOVE AND REPLACE)
HVAC ASSEMBLY (REMOVE AND REPLACE)
BLOWER MOTOR - HVAC (REMOVE AND REPLACE)
SENSOR - AMBIENT AIR TEMPERATURE (REMOVE AND REPLACE)
SENSOR - CABIN TEMPERATURE (REMOVE AND REPLACE)
SENSOR - TEMPERATURE - EVAPORATOR (REMOVE AND REPLACE)
SENSOR - TEMPERATURE - LH (REMOVE AND REPLACE)
SENSOR - TEMPERATURE - RH (REMOVE AND REPLACE)
1820 - REFRIGERANT SYSTEM
A/C REFRIGERANT LEAK DETECTION
A/C REFRIGERANT (RECOVERY AND RECHARGE)
CHILLER AND EXV ASSEMBLY (REMOVE AND REPLACE)
COMPRESSOR (REMOVE AND REPLACE)
CONDENSER (REMOVE AND REPLACE)
EVAPORATOR (CLEAN)
EVAPORATOR (REMOVE AND REPLACE)
MODULE - COOLING FAN (REMOVE AND INSTALL)
MODULE - COOLING FAN (REMOVE AND REPLACE)
MOUNTING - A/C COMPRESSOR (REMOVE AND REPLACE)
PIPE - HIGH PRESSURE - COMPRESSOR TO CONDENSER (REMOVE AND REPLACE)
PIPES - REFRIGERANT - HIGH / LOW PRESSURE (REMOVE AND REPLACE)
PRESSURE TRANSDUCER - HIGH PRESSURE (REMOVE AND REPLACE)
PRESSURE TRANSDUCER - LOW PRESSURE (REMOVE AND REPLACE)
RECEIVER DRYER AND DESICCANT (REMOVE AND REPLACE)
TXV VALVE - EVAPORATOR (REMOVE AND REPLACE)
1830 - COOLING SYSTEM
5-WAY VALVE (REMOVE AND REPLACE)
ACTUATOR - 5-WAY VALVE (DUAL MOTOR) (REMOVE AND REPLACE)
ACTUATOR - 5-WAY VALVE (RWD) (REMOVE AND REPLACE)
COOLANT PUMP - HV BATTERY (REMOVE AND REPLACE)
COOLANT PUMP - POWERTRAIN (REMOVE AND REPLACE)
COOLING SYSTEM (CHECK AND FILL)
COOLING SYSTEM (DRAIN AND REFILL)
COOLING SYSTEM (PARTIAL REFILL AND BLEED)
COOLING SYSTEM (VACUUM REFILL)
HOSE - CHILLER TO CAR COMPUTER AND HV BATTERY SUPPLY MANIFOLD (DUAL MOTOR) (REMOVE AND REPLACE)
HOSE - RETURN - HV BATTERY (REMOVE AND REPLACE)
HOSE - RETURN - POWERTRAIN (REMOVE AND REPLACE)
HOSE - SUPPLY - POWERTRAIN (REMOVE AND REPLACE)
RADIATOR (REMOVE AND REPLACE)
SUPERBOTTLE (DUAL MOTOR) (REMOVE AND REPLACE)
SUPERBOTTLE (RWD) (REMOVE AND REPLACE)
1850 - AIR DISTRIBUTION
ACTIVE GRILLE SHUTTER (REMOVE AND REPLACE)
20 - SAFETY AND RESTRAINT
2001 - AIRBAGS
AIRBAG - CURTAIN - LH (REMOVE AND REPLACE)
AIRBAG - DRIVER (REMOVE AND REPLACE)
AIRBAG - FRONT PASSENGER (REMOVE AND INSTALL)
AIRBAG - FRONT PASSENGER (REMOVE AND REPLACE)
AIRBAG - KNEE - DRIVER (REMOVE AND INSTALL)
AIRBAG - KNEE - DRIVER (REMOVE AND REPLACE)
AIRBAG - KNEE - FRONT PASSENGER (REMOVE AND REPLACE)
AIRBAG - SIDE - DRIVER (REMOVE AND REPLACE)
MODULE - RESTRAINT CONTROL (REMOVE AND REPLACE)
2005 - SEATBELTS
BUCKLE - 1ST ROW - LH (REMOVE AND REPLACE)
BUCKLE - 2ND ROW - CENTER (REMOVE AND REPLACE)
BUCKLE - 2ND ROW - LH (REMOVE AND REPLACE)
ADJUSTABLE TOP LOOP (REMOVE AND REPLACE)
SEATBELT - 1ST ROW - LH (REMOVE AND REPLACE)
SEATBELT - 2ND ROW - CENTER (REMOVE AND REPLACE)
SEATBELT - 2ND ROW - LH (REMOVE AND REPLACE)
2010 - PRETENSIONERS
PRETENSIONER - OUTBOARD LAP - 1ST ROW - LH (REMOVE AND REPLACE)
2020 - SENSORS
SENSOR - AIRBAG - B-PILLAR - LH (REMOVE AND REPLACE)
SENSOR - AIRBAG - C-PILLAR - LH (REMOVE AND REPLACE)
SENSOR - AIRBAG - DOOR - FRONT (REMOVE AND REPLACE)
SENSOR - AIRBAG - FRONT - CENTER (REMOVE AND REPLACE)
SENSOR - AIRBAG - FRONT - LH (REMOVE AND REPLACE)
21 - INFOTAINMENT
2105 - TOUCHSCREEN
TOUCHSCREEN (REMOVE AND REPLACE)
2115 - CAR COMPUTER
CAR COMPUTER (REMOVE AND REPLACE)
CONNECTIVITY BOARD - CAR COMPUTER (REMOVE AND REPLACE)
SD CARD - CAR COMPUTER (REMOVE AND REPLACE)
SIM CARD - CAR COMPUTER (REMOVE AND REPLACE)
2121 - AUDIO SYSTEM - SPEAKERS SUBWOOFER AMPLIFIER
AMPLIFIER - AUDIO - EXTERNAL (REMOVE AND REPLACE)
SPEAKER - DASH - CENTER (REMOVE AND REPLACE)
SPEAKER - DASH - LH (REMOVE AND REPLACE)
SPEAKER - EMERGENCY (REMOVE AND REPLACE)
SPEAKER - FRONT DOOR - LH (REMOVE AND REPLACE)
SPEAKER - PARCEL SHELF - LH (REMOVE AND REPLACE)
SUBWOOFER (REMOVE AND REPLACE)
TWEETER - DASH (REMOVE AND REPLACE)
TWEETER - FRONT DOOR - LH (REMOVE AND REPLACE)
2125 - AUDIO SYSTEM - BLUETOOTH
MICROPHONE - BLUETOOTH (REMOVE AND REPLACE)
2126 - AUDIO SYSTEM - USB MEDIA PORT
USB HUB - CENTER CONSOLE - FRONT (REMOVE AND REPLACE)
USB HUB - CENTER CONSOLE - REAR (REMOVE AND REPLACE)
2130 - ANTENNA - FM HD RADIO
AMPLIFIER - ANTENNA - FM (REMOVE AND REPLACE)
TUNER - FM / HD (REMOVE AND REPLACE)
2131 - ANTENNA - SATELLITE RADIO
2132 - ANTENNA - GPS
ANTENNA - GPS (REMOVE AND REPLACE)
2133 - ANTENNA - WI-FI
ANTENNA - WI-FI (REMOVE AND REPLACE)
30 - CHASSIS
3001 - CHASSIS AND SUBFRAMES
ISOLATOR - MOTOR MOUNT - FRONT - LH (REMOVE AND REPLACE)
SUBFRAME ASSEMBLY - FRONT (DUAL MOTOR) (REMOVE AND INSTALL)
SUBFRAME ASSEMBLY - FRONT (DUAL MOTOR) (REMOVE AND REPLACE)
SUBFRAME ASSEMBLY - FRONT (RWD) (REMOVE AND INSTALL)
SUBFRAME ASSEMBLY - FRONT (RWD) (REMOVE AND REPLACE)
SUBFRAME ASSEMBLY - REAR (REMOVE AND INSTALL)
SUBFRAME ASSEMBLY - REAR (REMOVE AND REPLACE)
31 - SUSPENSION
3100 - ADJUSTMENT
FOUR WHEEL ALIGNMENT (CHECK)
FOUR WHEEL ALIGNMENT (CHECK AND ADJUST)
3101 - FRONT SUSPENSION (INCLUDING HUBS)
FRONT UPPER CONTROL ARM (FUCA) MOUNT - LH (REMOVE AND REPLACE)
CONTROL ARM - UPPER - FRONT - LH (REMOVE AND REPLACE)
HUB - FRONT - LH (DUAL MOTOR) (REMOVE AND REPLACE)
HUB - FRONT - LH (RWD) (REMOVE AND REPLACE)
KNUCKLE - SUSPENSION - FRONT - LH (DUAL MOTOR) (REMOVE AND REPLACE)
KNUCKLE - SUSPENSION - FRONT - LH (RWD) (REMOVE AND REPLACE)
LINK - COMPLIANCE - LOWER - FRONT - LH (REMOVE AND REPLACE)
LINK - LATERAL - LOWER - FRONT - LH (REMOVE AND REPLACE)
LINK - STABILIZER BAR - FRONT - LH (REMOVE AND REPLACE)
STABILIZER BAR - FRONT (REMOVE AND REPLACE)
SUSPENSION - FRONT (CHECK TORQUE)
3103 - REAR SUSPENSION (INCLUDING HUBS)
COVER - REAR SUSPENSION - LH (REMOVE AND REPLACE)
DROP LINK - STABILIZER BAR - REAR - LH (REMOVE AND REPLACE)
HUB - REAR - LH (REMOVE AND REPLACE)
KNUCKLE - SUSPENSION - REAR - LH (REMOVE AND REPLACE)
LINK - AFT - LOWER - REAR - LH (REMOVE AND REPLACE)
LINK - FORE - LOWER - REAR - LH (REMOVE AND REPLACE)
LINK - FORE - UPPER - REAR - LH (REMOVE AND REPLACE)
STABILIZER BAR - REAR (REMOVE AND REPLACE)
SUSPENSION - REAR (CHECK TORQUE)
TOE LINK - REAR - LH (REMOVE AND REPLACE)
3115 - COIL SUSPENSION SYSTEM
DAMPER - REAR - LH (COIL SUSPENSION) (REMOVE AND REPLACE)
SPRING - REAR SUSPENSION - LH (REMOVE AND REPLACE)
SPRING AND DAMPER ASSEMBLY - FRONT - LH (REMOVE AND REPLACE)
32 - STEERING
3201 - STEERING RACK AND LOWER COLUMN
MODULE - STEERING COLUMN CONTROL (REMOVE AND REPLACE)
STEERING RACK (DUAL MOTOR) (REMOVE AND REPLACE)
STEERING RACK (RWD) (REMOVE AND REPLACE)
TIE ROD END - LH (REMOVE AND REPLACE)
3205 - UPPER COLUMN STEERING WHEEL STEERING LOCK
STEERING COLUMN (REMOVE AND REPLACE)
STEERING WHEEL (REMOVE AND INSTALL)
STEERING WHEEL (REMOVE AND REPLACE)
33 - BRAKES
TORQUE SPECIFICATIONS - BRAKES
3301 - BRAKE DISCS AND CALIPERS
BRAKE CALIPER - FRONT - LH (REMOVE AND REPLACE)
BRAKE CALIPER - REAR - LH (REMOVE AND REPLACE)
BRAKE PADS - BURNISHING
BRAKE PAD KIT - FRONT (BASE BRAKES) (REMOVE AND REPLACE)
BRAKE PAD KIT - FRONT (SPORT BRAKES) (REMOVE AND REPLACE)
BRAKE PAD KIT - REAR (BASE BRAKES) (REMOVE AND REPLACE)
BRAKE PAD KIT - REAR (SPORT BRAKES) (REMOVE AND REPLACE)
BRAKE ROTOR - FRONT - LH (REMOVE AND REPLACE)
BRAKE ROTOR - REAR - LH (REMOVE AND REPLACE)
SHIELD - DUST - BRAKE - FRONT - LH (REMOVE AND REPLACE)
SHIELD - DUST - BRAKE - REAR - LH (REMOVE AND REPLACE)
SHIELD - DUST - BRAKE - REAR - LH AND RH (RETROFIT)
3303 - BRAKE PIPES AND HOSES
BRAKE FLUID BLEED - ONE CALIPER
BRAKE FLUID BLEED / FLUSH
BRAKE FLUID CHECK
BRAKE HOSE - FLEXIBLE - FRONT - LH (REMOVE AND REPLACE)
BRAKE HOSE - FLEXIBLE - REAR - LH (REMOVE AND REPLACE)
BRAKE LINES - 4 TUBE BUNDLE - ABS TO WHEELS (REMOVE AND REPLACE)
BRAKE LINES - LH SILL (REMOVE AND REPLACE)
BRAKE LINES - MASTER CYLINDER TO ABS (REMOVE AND REPLACE)
BRAKE LINES - REAR - LH TO SILL (REMOVE AND REPLACE)
BRAKE LINES - REAR - RH TO SILL (REMOVE AND REPLACE)
3305 - PARKING BRAKE
PARKING BRAKE - CALIPER - REAR - LH (RELEASE)
3310 - ABS TRACTION AND STABILITY CONTROL
ABS MODULATOR (REMOVE AND REPLACE)
SENSOR - WHEEL SPEED - ABS - FRONT - LH (REMOVE AND REPLACE)
SENSOR - WHEEL SPEED - ABS - REAR - LH (REMOVE AND REPLACE)
3320 - BRAKE BOOSTER
BOOSTER - BRAKE - ELECTROMECHANICAL (LHD) (REMOVE AND REPLACE)
MASTER CYLINDER AND RESERVOIR ASSEMBLY (REMOVE AND REPLACE)
3325 - BRAKE PEDAL
BRAKE PEDAL (REMOVE AND REPLACE)
SWITCH - BRAKE LIGHT (REMOVE AND REPLACE)
34 - WHEEL AND TIRES
3401 - WHEELS
CAP - WHEEL (REMOVE AND REPLACE)
WHEEL (REMOVE AND INSTALL)
3402 - TIRES
TIRE - FRONT - LH (DISMOUNT AND MOUNT)
TIRE - FRONT - LH (REBALANCE)
TIRE - FRONT - LH (REPAIR)
TIRE ROTATION
3404 - TIRE PRESSURE MONITORING SYSTEM (TPMS)
MODULE - TPMS (REMOVE AND REPLACE)
MODULE - TPMS (SENSOR ID LEARN)
SENSOR - TPMS (REMOVE AND REPLACE)
39 - FRONT DRIVE UNIT
3901 - FRONT DRIVE UNIT ASSEMBLY
BUSHING – FRONT DRIVE UNIT – RH (REMOVE AND REPLACE)
DRIVE UNIT - FRONT (REMOVE AND INSTALL)
DRIVE UNIT - FRONT (REMOVE AND REPLACE)
GROUND STRAP - FRONT DRIVE UNIT (REMOVE AND REPLACE)
MOUNT - FRONT DRIVE UNIT - LH (REMOVE AND REPLACE)
3920 - FRONT DRIVE INVERTER
HOSE - INVERTER INLET - FRONT DRIVE UNIT (REMOVE AND REPLACE)
HOSE - INVERTER TO HEAT EXCHANGER - FRONT DRIVE UNIT (REMOVE AND REPLACE)
3930 - FRONT GEARBOX AND HALFSHAFTS
BREATHER - FRONT DRIVE UNIT (REMOVE AND REPLACE)
BUSHING - GEARBOX - FRONT DRIVE UNIT (REMOVE AND REPLACE)
FILTER - OIL - FRONT DRIVE UNIT (REMOVE AND REPLACE)
GEARBOX FLUID - FRONT DRIVE UNIT (DRAIN AND REFILL)
HALFSHAFT - FRONT DRIVE UNIT - LH (REMOVE AND REPLACE)
HEAT EXCHANGER - FRONT DRIVE UNIT (REMOVE AND REPLACE)
HOSE - HEAT EXCHANGER TO SUPERBOTTLE - FRONT DRIVE UNIT (REMOVE AND REPLACE)
OIL PUMP - FRONT DRIVE UNIT (REMOVE AND REPLACE)
OIL SCREEN - FRONT DRIVE UNIT (REMOVE AND REPLACE)
SEAL - OIL - DIFFERENTIAL TO HALFSHAFT - FRONT DRIVE UNIT - LH (REMOVE AND REPLACE)
40 - REAR DRIVE UNIT
4001 - REAR DRIVE UNIT ASSEMBLY
BUSHING - REAR DRIVE UNIT - REAR (REMOVE AND REPLACE)
BUSHING - REAR DRIVE UNIT - RH (REMOVE AND REPLACE)
FLUID COUPLING (55 DEGREES) - REAR DRIVE UNIT (REMOVE AND REPLACE)
FLUID COUPLING (STRAIGHT) - REAR DRIVE UNIT (REMOVE AND REPLACE)
DRIVE UNIT - REAR (REMOVE AND INSTALL)
DRIVE UNIT - REAR (REMOVE AND REPLACE)
MOUNT - REAR DRIVE UNIT - LH (REMOVE AND REPLACE)
4010 - REAR MOTOR
MOTOR ASSEMBLY - REAR (REMOVE AND REPLACE)
SENSOR - REAR MOTOR - SPEED (REMOVE AND REPLACE)
4020 - REAR DRIVE INVERTER
HV HEADER - INVERTER - REAR DRIVE UNIT (REMOVE AND REPLACE)
INVERTER AIR LEAK TEST
INVERTER COOLANT LEAK TEST
INVERTER - REAR DRIVE UNIT (REMOVE AND INSTALL)
INVERTER - REAR DRIVE UNIT (REMOVE AND REPLACE)
POWERTRAIN COOLANT (DRAIN AND REFILL)
4030 - REAR GEARBOX AND HALFSHAFTS
BREATHER - REAR DRIVE UNIT (REMOVE AND REPLACE)
FILTER - OIL - REAR DRIVE UNIT (REMOVE AND REPLACE)
GEARBOX - REAR DRIVE UNIT (REMOVE AND REPLACE)
GEARBOX FLUID - REAR DRIVE UNIT (DRAIN AND REFILL)
HALFSHAFT - REAR DRIVE UNIT - LH (REMOVE AND REPLACE)
HEAT EXCHANGER - REAR DRIVE UNIT (REMOVE AND REPLACE)
OIL PUMP - REAR DRIVE UNIT (REMOVE AND REPLACE)
OIL SCREEN - REAR DRIVE UNIT (REMOVE AND REPLACE)
SEAL - OIL - DIFFERENTIAL TO HALFSHAFT - REAR DRIVE UNIT - LH (REMOVE AND REPLACE)
44 - HIGH VOLTAGE SYSTEM
4401 - CHARGE SYSTEM INLET
CARRIER ASSEMBLY - CHARGE PORT (REMOVE AND REPLACE)
CHARGE PORT - MANUAL RELEASE OF CABLE
CHARGE PORT VOLTAGE CHECK
DEADFRONTS - PIN - CHARGE PORT (NA) (REMOVE AND REPLACE)
DOOR AND HINGE COVER - CHARGE PORT (REMOVE AND REPLACE)
DOOR ASSEMBLY - CHARGE PORT (NA) (REMOVE AND REPLACE)
DOOR ASSEMBLY - CHARGE PORT (CHINA) (REMOVE AND REPLACE)
ECU - CHARGE PORT (REMOVE AND REPLACE)
LATCH ACTUATOR - CHARGE PORT (REMOVE AND REPLACE)
4450 - HV HARNESSES
HARNESS - CHARGE PORT TO HV BATTERY (SINGLE-PHASE) (REMOVE AND REPLACE)
HARNESS - CHARGE PORT TO HV BATTERY (THREE-PHASE) (REMOVE AND REPLACE)
HARNESS - HV BATTERY TO FRONT DRIVE UNIT (REMOVE AND REPLACE)
HARNESS - HV BATTERY TO PTC HEATER AND A/C COMPRESSOR (DUAL MOTOR) (REMOVE AND REPLACE)
HARNESS - HV BATTERY TO PTC HEATER AND A/C COMPRESSOR (RWD) (REMOVE AND REPLACE)
HARNESS - HV BATTERY TO REAR DRIVE UNIT (REMOVE AND REPLACE)
50 - EXTERNAL CHARGING CONNECTORS
5001 - MOBILE CONNECTOR
FIRMWARE UPDATE - CHADEMO CHARGING ADAPTER
4401 - CHARGE SYSTEM INLET
4401 - Charge System Inlet
Related links
Carrier Assembly - Charge Port (Remove and Replace)
Correction code
44012102
Charge Port - Manual Release of Cable
Correction code
44013205
Charge Port Voltage Check
Correction code
44012100
Deadfronts - Pin - Charge Port (NA) (Remove and Replace)
Correction code
44012112
Door and Hinge Cover - Charge Port (Remove and Replace)
Correction code
44011702
Door Assembly - Charge Port (NA) (Remove and Replace)
Correction code
44011502
Door Assembly - Charge Port (China) (Remove and Replace)
Correction code
44014302
ECU - Charge Port (Remove and Replace)
Correction code
44015002
Latch Actuator - Charge Port (Remove and Replace)
Correction code
44014002
Carrier Assembly - Charge Port (Remove and Replace)
Charge Port - Manual Release of Cable
Charge Port Voltage Check
Deadfronts - Pin - Charge Port (NA) (Remove and Replace)
Door and Hinge Cover - Charge Port (Remove and Replace)
Door Assembly - Charge Port (NA) (Remove and Replace)
Door Assembly - Charge Port (China) (Remove and Replace)
ECU - Charge Port (Remove and Replace)
Latch Actuator - Charge Port (Remove and Replace)
Parent topic:
44 - High Voltage System
